Kenworth T410 - Master Lubrication Chart

To Next Page

To Previous Page

SECTION THREE

MAINTENANCE & LUBRICATION

SCHEDULES

Main Page

Table of Contents7
List of Tables15
About this Handbook17
Safety Symbols19
Vehicle Safety20
- A Special Word about Repairs21
Driver Information Pack (Dip)22
- Electronic Customised Maintenance Manual (ECMM)22
- Electronic Customised Parts Catalogue (ECPC)22
- PACCAR Customer Support Directory22
- Master Service Chart23
General Information27
Vehicle Access27
- Door Lock and Keys27
Ignition Key Switch27
- Remote Keyless Entry (RKE)28
- Remote Verification29
Keypad Transmitter30
- Programming30
Cab and Frame Access31
- Safety31
- Climbing Onto the Deck Plate32
Engine Access34
- Hood Hold-Downs34
- Tilting the Hood35
- Hood Safety Latch36
Safe Vehicle Operation37
Vehicle Loading37
Emergency Equipment38
Driver's Checklist38
Approaching Your Vehicle39
Daily Checks40
- Engine Compartment40
- Chassis and Cab40
Pre-Start Checks42
- Daily Operations42
- Weekly Operations43
Air Loss Emergency Procedure43
Instrument Panel44
Typical T410 Dash Layout44
- Main Instrument Cluster46
Operating Temperatures52
Operating Pressures52
- Driver Performance Center53
- Warning Symbols70
- Description of Warning Symbols75
- Dash Switches84
Steering Column and Controls97
- Tilt/Telescoping Steering Column97
- Turn Signal/High Beam Switch99
- High Beam100
- Windscreen Wipers/Washer101
- Controls on Right Hand Side of the Steering Column103
Steering Wheel Controls (Optional)104
- Cruise Control105
- Horn105
Door Mounted Controls106
Curb Side Mirror109
Cab Hvac Controls110
- Buttons and Dials115
- Operating Tips117
- Cab Air Distribution119
Radio (Option)120
Interior Storage Compartments120
- Toolboxes120
Ignition Key Switch121
Vehicle Telematic System122
Seats124
- Seat Adjustment124
Safety Restraint Belts125
- Lap & Shoulder Belt126
- Sleeper - Bunks and Restraints127
Operating the Engine128
- Normal Starting Procedure128
- Engine Warm-Up129
- Idling the Engine132
Engine Aftertreatment Systems (Eas)133
- PACCAR MX-13 Engine with Selective Catalytic Reduction (SCR)133
- Adblue Low Level Warning and Inducement133
- EAS System Tampering134
- Diesel Exhaust Fluid - Adblue Quantity134
- Engine Derate' Means; Engine Power Limiting134
- Diesel Exhaust Fluid - Adblue135
- Adblue Filling136
Engine Brake Operation137
Operating the Transmission139
- Putting the Vehicle in Motion139
- Shifting Gears in a New Vehicle140
- Clutch Brake and Travel141
- Double Clutching142
Clutch Operation143
- Starting143
- Transmission Oil Temperature Gauge144
- Transmission Shift Patterns145
Automated Transmissions146
Controls for Vehicles with a Paccar or Eaton Automated Transmission147
Paccar Transmissions149
- Start-Up and Power-Down150
- PACCAR Transmission Modes151
- PACCAR Transmission Features154
Eaton Transmissions157
- Ultrashift PLUS Transmissions157
- Start-Up and Power-Down159
- Eaton Transmission Modes160
- Ultrashift PLUS Features166
- Driver Diagnosis - Ultrashift169
- Retrieving Fault Codes169
- Fault Codes170
Using the Brake System172
Air Supply System172
Brake Operation173
Using the Parking Brake174
- Before You Leave the Cab174
- To Release the Truck Parking Brake Only174
- To Release the Full Combination of Brakes175
Truck/Trailer Air Supply Valve175
- Trailer Parking Brake Release Valve176
- System Truck Park177
- Brake Safety and Emergency177
- Emergency Braking178
Disc Brakes179
Electronic Brake Safety System (Ebss)180
- Anti-Lock Braking System (ABS)180
- ABS Warning Lamp180
- Automatic Traction Control (ATC)180
- Drag Torque Control (DTC)181
- Electronic Stability Program (ESP)182
- Trailer Response Management (TRM)182
- ABS Off-Road Function Switch182
Hill Start Assist (Hsa)183
Fusion - Active Safety System184
- System Overview185
- Active Cruise with Braking186
- Forward Detected Vehicle Icon188
- Alerts and Warnings189
- Impact Alert / Collision Mitigation Braking190
- Following Distance Alert191
- Stationary Object Alert192
- Stationary Vehicle Braking193
- Lane Departure Warning194
- Potential False Alerts196
- How Your Actions Impact the Fusion System199
- System Maintenance and Troubleshooting200
- What to Expect When Using the Fusion System202
Trailer Brake Hand Valve205
Driving Bobtail or with an Unloaded Trailer206
Engine Brakes206
Operating the Rear/Drive Axle207
- Driver Controlled Differential Lock (DCDL)207
- Inter-Axle Differential Lock (Power Divider)208
- Inter-Axle Differential Lock Operation208
- Tridem Drive Axles209
Towing with Axles Fitted with Dcdl210
- Dual Range (Two-Speed) Rear Axle210
- Dual Range Axle Operation211
- Starting up211
Drive Axle Temperature Gauge213
Driving Tips and Techniques214
Instructions to Prevent Jackknifing217
Economical Driving219
- Safe Driving221
Air Suspension223
Fifth Wheel224
- Fifth Wheel Jaw Lock224
- Hook-Up224
- Air Activated 5 Th Wheel Release Procedure224
- Fifth Wheel Lubrication225
Tow Hitch225
Towing225
- Returning Vehicle to Service226
Vehicle Recovery and Spring Brakes226
- Vehicle Recovery Guidelines226
- Recovery Hitch Connection228
Spring Brakes - Manual Release231
Shut-Down234
- Before Stopping the Engine234
Engine Idle Timer234
Refuelling235
- Fuel Specification236
- Location of Fuel Shut-Off Valves236
Introduction240
- Environmental Protection and Material Hazards240
Safety Precautions241
Lubrication Specifications - Engine242
Fuel System247
- Fuel Specifications247
- Fuel System Priming247
- Fuel Tank Strap Tension249
Air Cleaner Systems250
- Air Cleaners and Filter Replacement250
- Air Intake System250
Accessory Drive Belts251
- Serpentine Belts251
Cooling System254
- Coolant254
Brake System257
Brake Linings258
Automatic Slack Adjusters259
- Free Stroke Measurement259
- Adjusted Chamber Stroke260
Automatic Brake Adjuster Application260
Anti-Lock Braking System (Abs)261
- ABS Fault Codes261
Air Supply System263
- Air System Function Test264
- Air Tanks264
- Water Ejection Valves264
Air Compressor265
- Operation265
- Air Gauges and Air Leaks266
Turbocharger267
Tyres268
- Tyre Inflation and Loading268
- Tyre Inspection and Replacement268
- Tyre Inflation269
Recommended Laden Tyre Pressures269
Maximum Vehicle Load Rating271
- Replacing Tyres272
- Matching Tyres272
Wheel Nut Torques273
Wheel Cap Nut Torque273
- Wheel Mounting and Fastening273
Vehicle Jacking274
- 20 Tonne Hydraulic Bottle Jack274
Jack Operating Instructions275
- Storage of the Vehicle Jack277
- Vehicle Jacking Points277
Batteries278
- Battery Charging279
- Maintenance-Free Batteries282
Hydrometer Readings282
- Electrical Systems - 12 Volt283
- Jump-Starting Vehicles283
Welding Precautions286
Chassis and Cab - Finish, Appearance and Cleaning287
- Chassis and Cab287
Smart (Steering) Wheel290
- Care/Maintenance290
- Cleaning290
Cab Heater/Airconditioning291
- Special Precautions291
- Cab Heater/Airconditioner292
- Airconditioner293
Safety Restraint System294
- Inspection Guidelines295
Transmission and Clutch298
- All Transmissions298
- Transmission Service Intervals299
Clutch System299
- General Information299
- Clutch Adjustment - Normal Wear300
- Clutch Adjustment301
- Clutch Lubrication302
Steering304
- Understeer and Oversteer304
- Axle Stops305
Hydraulic Power Steering305
- Filter Service and Parts - Reservoir Assembly305
- Steering Driveline306
- Driveshaft306
- U-Joints306
Adjustable Steering Column307
Front Axle and Suspension308
- Axle Lubrication308
- Kingpin Lubrication308
- Suspension Lubrication308
- Visual Inspection309
U-Bolt Tension for Front and Rear Axles309
Spring Suspension U-Bolts Grade 8310
Wheel Alignment311
- Front Wheel Alignment311
- Wheel Bearing Adjustment311
Rear Axle and Suspension312
- General Maintenance312
- Rear Suspension Fasteners312
- Visual Inspection313
Rear Axle Lubrication314
- Dana Rear Axle314
- Meritor Rear Axle314
- Axle Housing Breather Vent (All Axles)314
Rear Axle Alignment315
Torque Requirements Frame Fasteners316
Rear Suspension Alignment316
Noise Control System317
Air System Silencers318
- Inspection and Maintenance319
Magnetic Drain Plugs322
Torque Specifications323
- Grade 5 Fasteners323
- Grade 8 Fasteners324
Customer Information and Vehicle Identification325
Vehicle Identification Number (Vin)327
Serial Numbers and Capacities328
Australia Wide Roadside Assistance329
Schedules331
The Environment332
Introduction335
Change of Address/Ownership335
Warranty Questions336
Kenworth Dealer Network340
Maintenance Services Are the Owner'sresponsibility340
Lubrication Schedules341
- T410 - MX Engine Service Schedule342
- First Service342
- A Service Intervals343
- B Service Intervals343
- C Service Intervals350
Vehicle Lubrication Points Diagram352
- Vehicle Lubrication Points Legend354
Master Lubrication Chart357
Master Lubrication Chart358
Lubrication and Fluid Capacities359
Lubrication & Fluid Capacities359
A, B & C Service Intervals360
A, B & C Service Intervals361
- Section Four - Service Records369
Maintenance Service Records370
First Service Inspection Record371
Service Inspection Records373
Index407
Grade 5 Fastener Torques410
Grade 8 Fastener Torques410

Kenworth T410 - Master Lubrication Chart

Table of Contents

Related product manuals