Kingfisher 2525 - Common Electrical System Issues

KINGFISHER
O W N E R ’ S M A N U A L
w w w . k i n g f i s h e r b o a t s . c o m
23
Boat persistently smells of
gasoline
Fuel spilled into bilge/fuel
system leak
Check bilge for gasoline/evacuate
boat/inspect fuel system for leaks
Symptom
Probable Cause
Corrective Action
Engine runs hot
Low oil or coolant
Broken / stretched belt
Plugged water inlet
Damaged water pump or
thermostat
Check oil level/coolant level
(after engine cool down)
Replace broken/stretched
cooling system belt
Clear raw water intake
Replace raw water pump
Replace thermostat
Replace water pump impeller
Engine stops suddenly
Ignition or battery problems
Safety lanyard pulled
Check ignition wiring and fuse
Check battery connections
Check safety shut off lanyard
Check engine manufacturer’s
operations manual for more
detailed information
Boat persistently smells
of gasoline
Fuel spilled into bilge/fuel
system leak
Check bilge for
gasoline/evacuate
boat/inspect fuel system for
leaks
Erratic Steering
Trim set incorrectly
Steering system loose or
low on fluid
Adjust motor/drive trim
Tighten steering wheel
Bleed hydraulic lines
Check oil level
Electrical System
Trouble shooting an electrical problem:
o Check the circuit breakers on the control panel
o Check the main fuse
o Check wire lead connections
o Check for clean battery terminals
o Check battery for sufficient charge
Consult an authorised Kingfisher dealer if the problem persists.