LS tractor XR3037 - User Manual

104 pages

To Next Page

To Next Page

Loading...

LS L

O

INNOVATIVE

TECHNOLOGY

PARTNER

LS BA

C

O

ADER

LS LOADER

OPERATOR MANUAL

LS BACKHOE

C

KHOE

O

LB2100

TRACTOR Model

• I3030/I3030H/I3040/I3040H

•

R4010/R4010H/R4020/R4020H

O

PERATO

R

•

R4010/R4010H/R4020/R4020H

• XR3032/XR3032H/XR3037/XR3037H

• XR4040/XR4040H/XR4046/XR4046H

• XR3135/XR3135H/XR3140/XR3140H

• XR4140/XR4140H/XR4145/XR4145H

• XR4150/XR4150H/XR4155/XR4155H

• MT342/MT347/MT352/MT357

MT345E/MT350E/MT355E

R

MANUA

L

•

MT345E/MT350E/MT355E

L

PO Box 70, Battleboro, NC 27809

Tel

:

252

-

984

-

0700

LB

2

Tel

252

984

0700

Fax : 252-984-0701

www.lstractor.com

www.lstractorusa.com

2

100

P/NO

BT014-ME000

REVISION : 24

Table of Contents

Questions and Answers

T
Travis HodgesAug 19, 2025
How to troubleshoot swing, boom, dipperstick, and bucket cylinders on LS tractor?
- L
  lhowardAug 19, 2025
  If the swing, boom, dipperstick, and bucket cylinders on your LS tractor aren't working correctly, start by checking the hydraulic fluid level and replenishing if low. Ensure that all hydraulic hoses are properly connected and not blocked. Look for any damage to the hoses. Also, inspect the control valve linkage for breakage and repair if needed. Make sure the quick disconnect couplers are fully connected, and replace them if necessary. If the problem persists, there may be an issue with the cylinder piston assembly, and you should check the cylinders for internal leakage.
D
Dr. Melissa HamiltonAug 21, 2025
Why are the cylinders on my LS tractor moving slowly and erratically?
- A
  Amanda OrozcoAug 21, 2025
  If you notice slow or erratic cylinder movement, along with noisy operation in your LS tractor, there are several potential causes. First, ensure the hydraulic fluid level is adequate and replenish if necessary. Allow the hydraulic system to warm up, especially if the fluid is cold. Make sure the engine RPM is sufficient for proper hydraulic pump operation. Reduce the material load if it exceeds the backhoe's capacity. Check the control valve linkage for any binding or defects and repair if needed. Also, inspect hoses and tubelines for restrictions. If these steps don't resolve the issue, the cylinder piston assembly may be leaking, or the control valve may be internally leaking.
R
Richard WilliamsAug 23, 2025
Why does my LS tractor have inadequate lifting capacity?
- R
  raymondwebbAug 25, 2025
  If your LS tractor has inadequate lifting capacity, begin by increasing the engine RPM. Reduce the load if it exceeds the specified loader capacity. Inspect the relief valve setting and reset it as needed. Check the bucket, boom, and dipperstick cylinders for leakage and repair if necessary. If the issue continues, the control valve might be leaking internally, and it may need replacement.
R
Richard BaileyAug 26, 2025
What to do if hydraulic fluid aeration occurs in LS tractor?
- C
  Craig CarlsonAug 26, 2025
  If the hydraulic fluid in your LS tractor appears foamy, it indicates aeration. First, check and refill the hydraulic system to the correct level. Then, inspect for loose or defective connections between the reservoir and hydraulic pump that could be allowing air to leak into the suction side. Finally, make sure you are using the recommended hydraulic oil, and replace it if necessary.
J
Jared JohnsonAug 28, 2025
Why is the system relief valve squealing on my LS tractor?
- J
  Jennifer PerryAug 28, 2025
  If the system relief valve on your LS tractor is squealing, first check the hydraulic oil to ensure it has the correct number and viscosity, and refill if needed. Reduce the load if it exceeds the backhoe's specified capacity. Check and reset the valve setting as needed. Also, inspect the hydraulic hose, tubeline, or quick disconnect coupler for restrictions and repair or replace any defective components.
D
Dr. Paul Brown MDAug 30, 2025
How to fix external hydraulic fluid leakage in LS tractor?
- R
  Rebecca RamirezAug 30, 2025
  If you notice external hydraulic fluid leakage on your LS tractor, start by tightening any loose connections. Check for the origin of the oil leak and replace any defective hydraulic hoses, tubelines, adapter fittings, or adapter fitting o-rings. Replace any defective control valve o-rings. If the control valve spool or body is damaged or worn, replace the control valve. Also, check cylinders for leakage and repair as needed.
M
Mrs. Ann NashSep 1, 2025
What causes inadequate hydraulic pump capacity in LS tractor?
- T
  Teresa ReillySep 1, 2025
  If the hydraulic pump on your LS tractor has inadequate capacity, allow the hydraulic fluid to warm up to operating temperature. Increase the engine RPM. Check for evidence of restriction in hydraulic hoses.
J
jhurstSep 3, 2025
Why does the backhoe on my LS tractor drop when the control valve is centered?
- A
  ashley52Sep 3, 2025
  If the backhoe on your LS tractor drops when the control valve spool is in the centered position, and there's no external oil leakage, check the cylinders for leakage. If leakage is not the issue, the control valve may have internal leakage and may need to be replaced.
Z
zlawrenceSep 5, 2025
What to do if cylinders operate in wrong direction on LS tractor?
- D
  Debra GarciaSep 5, 2025
  If the cylinders on your LS tractor are operating in the wrong direction relative to the control valve lever position, the hydraulic hoses may be connected incorrectly. Correct the hydraulic hose connections to resolve this issue.
A
Allen OchoaSep 7, 2025
Why won't the control valve spool return to the centered position on my LS tractor?
- S
  Samuel MedinaSep 8, 2025
  If the control valve spool(s) on your LS tractor will not return to the centered position, determine the origin of any binding in the control lever linkage and repair it. If the control valve spool centering is broken, replace the centering spring. If the control valve spool is binding in the valve body spool bore, disassemble the valve for inspection and repair.

LS tractor XR3037 Specifications

General

Engine Type	Diesel
Engine Power	37 HP
Hydraulic System	Open Center
Lift Capacity	1, 808 lbs
Drive Type	4WD
Engine Cylinders	3
Transmission	Synchro Shuttle
Fuel Tank Capacity	9.5 gal

Summary

Warranty Conditions

Warranty Coverage

Details what the warranty covers for LS Mtron Tractor Division products.

Warranty Provisions

Outlines purchaser's obligations and warranty limitations for LS Mtron Loaders.

Safety Precautions

General Safety Guidelines

Covers operating, maintenance, and general safety practices for the backhoe.

Children Safety

Provides specific safety guidelines regarding children around machinery.

Road Driving Safety

Safety measures for transporting the backhoe on public roads.

Tractor Preparation

ROPS and Hydraulic System

Backhoe Operation

Precautionary Notes

Important safety and operational tips before starting.

Initial Operation

Steps for the first operation and familiarization with the backhoe.

Control Operations

Instructions for operating stabilizer, boom, swing, bucket, and crowd controls.

Digging Safety

Safety considerations during digging operations, including vertical walls.

Transporting Procedures

Backhoe Removal

Removal Steps

Detailed steps for detaching the backhoe from the tractor.

Backhoe Installation

Installation Steps

Detailed steps for attaching the backhoe to the tractor.

Lubrication and Maintenance

Weekly or Every 50 Hours Checks

Daily or Every 10 Hours Checks

Trouble Shooting

Cylinder Operation Issues

Troubleshooting common issues with cylinder movement and operation.

Lifting Capacity Problems

Identifying causes for insufficient lifting capacity.

Hydraulic Fluid Issues

Diagnosing and fixing hydraulic fluid leaks or foaming.

Pump Capacity Issues

Troubleshooting issues related to insufficient hydraulic pump performance.

Part Illustrations

Related product manuals

LS tractor XR3037H

Preview: LS tractor XR4140

LS tractor XR4140

LS tractor XR4046

LS tractor XR4150

LS tractor XR4155

LS tractor XR4040H

LS tractor XR4046H

Preview: LS tractor XG3025

LS tractor XG3025

Preview: LS tractor XG3032

LS tractor XG3032

Preview: LS tractor XU6158

LS tractor XU6158

LS tractor XG3037

LS tractor XG3025H