Mac Afric JdP12000 - Engine Operation and Maintenance; Starting and Stopping the Engine; Maintenance Schedule Overview

If operate imp1·opef'ly, the battery nuly explode, thus
1
injury n1ay occur fQ
the persons around, tl1ereforc) keep the smoke and Oa1ne and
inflnn1ntalJle
things a'v-ay front the battery. The battery "·Ill rel!.'.'!lSe
explosion gas, keep the fire i:nfay fron1 it. \Vhen charge the bnitery or use
the battery
1
keep ventilating.
5. Start engine
PO\\'ered start
1 ) Rem.ove aU loads on !be tenninals,
2) Open the fuel valve.
3) Tum off the AC circuit breaker.
4) Pull the choke bu1ton to "close" position,
'V11en the engine ls in 1\'arnling condition, do not close the choke.
5) Tum the start swilch to "start" position.
6) After starting the engine, relcuse the "start" switch irnmcdiuteiy, the switch will return
back to "n1n" position.
7) After warming up the engine, push the choke button to ''open" position.
( Note I
•Do not let lhe switch stay in "start'i position over 5 seco11ds~ or the starter uu1y be
dan1aged. If the engine can not he started at first thne, start the engine agaln at nn
intervnl of over 10 seconds.
·If the starter s11ecd degrades nfter using it a period orthne, it n1eans ehorgiug the
baHel'y
is necessary.
6. Slopping engine
1) Tum off lhe AC circuit breaker.
2) Turn off the engine s\vitch.
3) Close the fuel valve.
J Note l1r an en1ergency stop is necessnry, hwn off the enginl' switch dlreeUy.
7. Maintenance schedule
Good m1tlntenance and service gives an assurance that the generator runs in safety and
economy nnd without any failures, in the meanwhile it is in favor of environment protection.
II