Contaminated Organic
Material Can Build-Up,
Inside Chamber Housing
The Check Valve, From
Dirty Tub Water
Over Time
“O” Ring Built Into Bottom
of Exterior Check Valve
Seals 360 Degrees
Around Outer Flat of
Aerator Body Sealing
The Six 1/8” Air Ports
Inside The Body From
Contaminated Tub Water
When The Air Is Shut Off
Interior Check Valve
“O” Ring Seals 360
Degrees Around Inner
Angled Surface of
Valve’s Inside chamber
Housing Leaving The Air
Ports Open Filling The
Chamber With Contaminated
Tub Water When The Air
Is Shut Off During The Bath
Form 00033 C 05/06/11
1)
Common,
“off the shelf” aerator interior check valves do not seal the
air injection ports allowing contaminated bath water inside
the housing chamber. See the cut-a-way view below.
2)
The common, “off
the shelf” aerator body is not designed to be removed, in
its entirety, for cleaning and servicing.
3)
The
common, “O
4)
The common
“off the shelf “ aerators have no secondary check valve to
prevent contaminated water from entering the air lines in
the event of a primary check valve failure.
ff the shelf” aerator six ports are ½ the size
in area requiring significantly more of them to achieve
the same level of turbulence.
The exterior check valve seals the air injection ports
when air system shuts off preventing contaminated water
from entering the inside chamber of the body.
The entire aerator body can be easily removed with a
special tool for servicing and cleaning.
The six 1/8” air ports in each MasterCare aerator
reduces the number of
results in less time needed for cleaning &
maintenance and less chance for contamination.
The MasterCare Aerator has a secondary check valve
inside the housing to prevent water f
rom entering air lines
in the event the primary check valve fails.
aerators needed to create the
desired hydro-massage effect. This reduced number of
aerators
MasterCare’s BathAire Aerator Valve System
Compared To Common Off The Shelf Aerators
Common, “Off The Shelf”
Aerator Body
Approximate Size
MasterCare’s Custom Design
BathAire Aerator Body
Approximate Size
Blow Up Cut-A-Way View Of A Common
“Off The Shelf” Aerator Body Showing
The Check Valve In Inside Chamber Housing
Four Big Advantages Of Aerators
Over Common, “Off The Shelf” Aerators
MasterCare’s
Top View Of Off
The Shelf Aerator
Air Ports About
½ The Area of
A 1/8” Round Port
Top View Of MasterCare
Aerator With Six
1/8” Round Air Ports
= Inside Chamber Wall
Check
Valve
To Next Page
Loading...
