Mazda 323 1988 - Outline; Outline of Construction; Structural View

1129 pages

Save Page as PDF

To Next Page

To Previous Page

OUTLINE

OUTLINE OF CONSTRUCTION

Standard universal joints are installed on the propeller shaft,

STRUCTURAL VIEW

1, Propeller shaft

2. Driveshaft (front)

3. Joint shaft

4. Driveshaft (rear)

5. Rear differentail

8-2

Main Page

Table of Contents3
Important Information4
Fundamental Procedures5
Jack and Safety Stand (Rigid Rack) Positions8
Vehicle Lift (2-Support Type)8
Towing9
Maintenance Notes (4Wd Model)10
Chassis Number Location10
Abbreviations11
Units11
Outline21
Structural View21
Specifications22
Troubleshooting Guide22
Tune-Up Procedure24
On-Vehicle Maintenance30
Timing Belt30
11. Cylinder Head117
17. Valve Seal117
Disassembly117
Inspection and Repair125
Assembly138
Outline275
Emission Components275
Locations275
Component Descriptions276
Vacuum Routing Diagram278
Specifications279
Troubleshooting with285
Inspection Procedure285
Monitor Switch Function297
Idle Adjustment298
Intake Air System299
Removal and Installation301
Parts Inspection302
Air Bypass Valve303
Intercooler303
Troubleshooting Chart305
Fuel System308
Control326
System330
Troubleshooting Chart331
And Installation332
Control System336
Troubleshooting Chart337
System339
Purge Control Valve340
Valve341
Switch Valve342
Check Valve342
Crankcase343
(Pcv) System343
System351
Switch357
Outline363
Specifications363
Battery366
Inspection366
Recharging366
Alternator367
Charging System367
On-Vehicle381
Inspection381
Assembly385
Inspection388
Installation392
Installation397
Distributor (Non-Turbo)398
Troubleshooting399
Distributor (Turbo)399
Knock Control System (Turbo)400
Ignition Timing403
Removal404
Installation404
Disassembly and Assembly404
Troubleshooting (Turbo)407
Troubleshooting407
Pedal Height408
Pedal Freeplay408
Inspection409
Installation410
Clutch Cable411
Removal411
Inspection411
Inspection and Adjustment412
Clutch Pedal Height412
Clutchpedal Play412
Clutchpedal413
Removal and Installation413
Master Cylinder414
Removal and Installation414
Inspection417
Assembly417
Release Cylinder418
Removal and Installation418
Disassembly, Inspection and Assembly419
Clutch and Flywheel420
Installation423
Outline509
Structural View509
Cross-Sectional View510
Specifications511
Troubleshooting Guide512
Disassembly522
Inspection545
Assembly552
Installation590
Transaxle Control592
Outline596
Outline of Construction596
Structural View596
Specifications597
Troubleshooting Guide597
On-Vehicle Check598
Propeller Shaft599
Assembly Installation607
2Wd/4Wd608
Driveshaft625
INSPECTION (Non-Turbo)625
ASSEMBLY (Non-Turbo)626
Installation627
Front Axle629
Disassembly630
Inspection631
Assembly632
Installation635
Rear Axle636
REMOVAL Drum Brake636
Removal (Disc Brake)636
Inspection638
Outline642
Outline of Construction642
Structural View642
Specifications646
Troubleshooting Guide647
Rear Differential648
On-Vehicle Check648
On-Vehicle Maintenance648
Rear Driveshaft670
On-Vehicle Check670
Rear Axle673
Disassembly680
Outline685
Specifications686
Troubleshooting Guide687
Manual Steering689
On-Vehicle Maintenance689
Steering Wheel Play689
Looseness or Play of Steering689
Wheel689
Steering Wheel Effort689
Power Steering Fluid Level690
Loose or Damaged Oil Pump Belt690
Inspection and Adjustment692
Bleeding of Power Steering System692
Power Steering Pressure693
Front Wheel Alignment694
Tie-Rod End Boot697
Steering Wheel and Column701
Removal and Installation703
Steering Gear and Linkage704
Removal and Installation (2Wd)705
Disassembly (Manual Steering, Constant Gear Ratio Type)719
Disassembly (Manual Steering, Variable Gear Ratio Type)729
Oil Pump741
Disassembly and Assembly758
Outline800
Structural View800
Troubleshooting Guide802
Frontshockabsorberandspring804
Removal and Installation808
Front Stabilizer811
Removal and Installation813
Rearshockabsorberandspring813
Removal and Installation817
Rear Stabilizer819
Rear Wheel Alignment820
Pre-Inspection820
Toe-In820
Adjustable Shock982
Cruise Control System988
Acc Checker)989
Cruise Control Unit992
Clutch Switch, Brake Switch993
Center Differential Lock System997
Center Differential Lock Sensor Switch999
Rear Window Defroster1000
Blower Unit Removal1009
Blower Control Resistor1010
Audio System1011
Outline of Audio System1011
Rear View and Connectors1012
Lubrication System1031
Cooling System1033
Fuel and Emission Control System1034
Automatic Transaxle1040
Propeller Shaft1045
Front and Rear Axles1046
Steering System1046
Braking System1047
Wheel and Tire1049
Body Electrical System1051
Standard Bolt and Nut Tightening Torque1052

Mazda 323 1988 - Outline; Outline of Construction; Structural View

Table of Contents

Related product manuals