Mercury HP 500 EFI Bravo XR/XZ/III - Page 8

4 500 EFI Bravo
TABLE OF CONTENTS
Page
Cold Weather or Extended Storage
Power Package Lay-up 122. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Draining Instructions 125. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Winter Storage 128. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Package Recommissioning 128. . . . . . . . . . . . . . . . . . . .
Troubleshooting
Starter Motor Will Not Crank Engine, or Cranks Slow 129. . . .
Engine Will Not Start or Is Hard to Start 129. . . . . . . . . . . . . . . .
Engine Runs Rough, Misses, and/or Backfires 130. . . . . . . . . .
Poor Performance 131. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Excessive Engine Temperature 131. . . . . . . . . . . . . . . . . . . . . . .
Insufficient Engine Temperature 132. . . . . . . . . . . . . . . . . . . . . .
Low Engine Oil Pressure 132. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Will Not Come Up On Charge 132. . . . . . . . . . . . . . . . .
Power Trim Does Not Operate (Motor Doesn’t Run) 133. . . . .
Power Trim Does Not Operate (Motor Runs But Drive Unit
Does Not Move) 133. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Operates Hard, Binds, Has Excessive Free-
Play or Makes Unusual Sounds 134. . . . . . . . . . . . . . . . . . . . . .
Steering Wheel Turns Hard or Jerky 134. . . . . . . . . . . . . . . . . .
Block Water Pressure Is Below Specification 135. . . . . . . . . . .
Block Water Pressure Is Above Specification 135. . . . . . . . . . .
Water Flow Diagram
500 EFI Engine 136. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring Diagrams
Power Trim (Single Engine) 137. . . . . . . . . . . . . . . . . . . . . . . . . .
Power Trim (Dual Engine) 138. . . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument Wiring Harness 139. . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Service Assistance
Owner Service Assistance 140. . . . . . . . . . . . . . . . . . . . . . . . . . .
Ordering Literature
Ordering Literature 144. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .