TM
MATERIAL:
SCALE
TITLE
DRAWING SIZE
D
DRAWING No:
LINDENWOOD ILLINOIS
WHERE USED
CADD FILENAME:
REF. DRAWING
DR BY
APPV BY
DATE
APPVBYDATEPIF#
REV
REVISION
NOTED)
(EXCEPT AS
DO NOT SCALE DRAWING
DATE
*********************
ProE Drawing
This drawing was
created in ProE.
The orginial drawing
should only be
edited in ProE.
*********************
1.000
1.000
1.000
1.000
.500
1.000
1.000
3.500
00002-533-00
DETAIL, ASSEMBLY
PV 50" B&S
SHEET 1 OF 2
SEE DETAILS
50" PV
S:\00002\
00002-533-00
0.125
JKG 5/4/2010
JKG 5/4/2010
TABD
D1
10-0084
REVISED & REDRAWN, SEE OBS
PDF FOR PREVIOUS VERSIONS
5/10
JG JG
D2
10-0084
REPLACED IDLER SUB-ASSY WITH
POLY ROLLER DESIGN
5/10
JG JG
PART WEIGHT
ITEM PART NUMBER DESCRIPTION QTY
1 00115-156-XX WELD, PV 50" HOPPER 1
2 04049-045-00 DECAL, CAUTION 1
3 04003-804-XX LOCKNUT, 5/16-18 NYLON 3
4 04003-806-13 NUT, 5/16-18 SER FLANGE SS
SEE
B/M
5 00122-366-00 SHAFT, IDLER 1
6 00122-369-00 ROLLER, POLY 2
7
00115-124-00 WELD, TAKE UP BOLT
2
8 04003-802-XX NUT, 1/2-13 HEX JAM 4
9 00118-337-00 SUB-ASSEMBLY GEARBOX 1
10 04003-005-XX BOLT, 1/2-13 X 3/4 4
11 04004-001-XX LOCKWASHER, 1/2" MED SPLIT 4
12 00119-590-01 FORMING, GUARD, CONVEYOR, PV 1
13 04003-804-XX LOCKNUT, 3/8-16 NYLON 3
14 04004-002-20 FLATWASHER, 3/8" SS 2
15 04003-003-XX BOLT, 3/8-16 X 1 1/4 HH 6
16 04003-806-XX NUT, 3/8-16 SER FLANGE 9
17 04043-XXX-XX WELD, DRAG CHAIN 1
18 04003-806-XX NUT, 5/16-18 SER FLANGE 10
19 04003-032-XX BOLT, 5/16-18 X 3/4 CA
SEE
B/M
20 00119-60X-XX CHAINSHIELD, PV 2
21 00122-05X-XX FORM, FLOOR PV 1
22 04071-016-00 V-BELT, BX-48 1
23 04616-120-00 CABLE, SPREADER CONTROL 1
24 04009-001-01 KEY, WOODRUFF 1/4 X 7/8 1
25 00122-073-01 A, WIRELESS REMOTE PV 1
26 04003-002-XX BOLT, 5/16-18 X 3/4 HH 1
27 04622-008-00 COVER, CLUTCH 1
28 00104-822-XX RETAINER, CLUTCH 1
29 04003-001-XX BOLT, 1/4-20 X 3/4 HH 5
30 04003-806-XX NUT, 1/4-20 SER FLANGE 5
31 04145-075-00 ENGINE, 10.5 HP B &S W / VR 1
32 04031-007-00 KEY, 1/4" SQ X 1" 1
33 04070-021-00 PULLEY, DRIVER 1
34 04003-002-XX BOLT, 5/16-18 X 1 1/2 HH 3
35 04048-518-01 BOLT, L 1
36 04004-002-XX FLATWASHER, 5/16 2
37 04093-022-00 GROMMET 7/8 X 1 5/8" 1
38 04145-005-00 SOLENOID, GROUNDED 1
39 04604-004-00 CABLE, BATTERY BLACK 1
40 04616-067-02 CABLE, STARTER, 9", 6GA. RED 1
41 04003-033-XX BOLT, 3/8-16 X 1 1/4 CA 1
42 04607-027-00 CLAMP, CUSHIONED 1/2" 1
43 SEE B/M P, INSTR MANUAL PV 1
44 00104-802-00 ROD, BATTERY 2
45 04604-017-00 DOWN, HOLD 1
46 00110-819-XX WELD, FEEDGATE 7G 1
47 04624-001-01 KNOB, HAND 1
48 00119-587-XX WELD, SHROUD 14G PV 1
49 00112-734-00 ROD, PROP 1
50 04004-002-XX FLATWASHER, 3/8" 2
51 04010-016-01 PIN, 1/8" X 1" COTTER SS 1
52 04049-182-00 DECAL, DANGER 3
53 04049-199-00 DECAL, GASOLINE ONLY 1
54 04049-XXX-XX DECAL, SERIAL NUMBER 1
55 04093-021-00 TRIM, VINYL 2
56 04553-008-XX SKID, PV 1
57 04003-033-14 BOLT, 3/8-16 X 4" CA 4
58 04605-155-00 CABLE, LIGHT POWER 1
59 04605-154-00 GROMMET, MTG 1
60 04540-003-00 OIL, 5W30 MOTOR
SEE
B/M
61 00118-312-XX FORM, HANDLE FEEDGATE 1
62 04605-153-00 LAMP, STOP CHM 1
63 04049-XXX-XX DECAL, LOGO 3
64 04003-033-12 BOLT, 3/8-16 X 3/4 CA SS 1
65 00101-636-XX BAR, PIVOT 1
66 04120-078-01 HOSE, 3/8" X 13" 1
67 04110-006-18 ELBOW, 3/8" 90 DEG 1
68 04045-022-00 PIN, CONNECTOR W/ COTTER PIN 2
69 04604-004-01 CABLE, BATTERY RED 1
70 04067-032-00 BOOT, BATT CABLE 1
71 04067-033-00 BOOT, ALT CABLE 3
72 04076-100-00 WIPER, CHAIN 1
73 SEE B/M WELD, SCREEN
SEE
B/M
74 SEE B/M WELD, INV. VEE 1
75 04003-032-04 BOLT, 5/16 X 1 CA SS 4
76 04070-020-00 PULLEY, DRIVEN 1
77 04138-017-00 CLUTCH, ELECTRIC 1
78 00108-771-00 WASHER, CLUTCH RET 1
79 04004-001-XX LOCKWASHER, 5/16 MED SPLIT 3
80 04003-081-04 5/16 X 5/8 SH CAP 3
81 04111-053-00 CAP, IDLER 2
82 04607-028-00 CLAMP, PROP ROD 1
83 04049-357-00 DECAL, ENGINE WARRANTY 1
84 04049-362-00 DECAL, FUEL SHUT OFF 1
85 04003-127-01 SCREW, 10-32 X 5/16 PPH ZP 2
86 04150-044-01 ACTUATOR, 12V 1
87 00117-256-00 LINKAGE, THROTTLE 1
88 00117-257-00 BRACKET, ACTUATOR 1
89 04003-069-01 SCREW, 8-32 X 3/4" SS 3
90 04004-002-59 FLATWASHER, #8 3
91 04003-804-28 LOCKNUT, 8-32 NYLON SS 3
92 00107-662-00 INSTR. PACKAGE B &S 1
93 04607-013-00 TIE, NYLON 5 1/2" STD 5
94 00002-296-XX P, ASSY SPNR 14 GA 1
95 04616-101-00 ASSY, GROUND WIRE 1
96 04525-012-XX POWDER PAINT
SEE
B/M
97 00122-181-XX A, LIFT REAR FORKLIFT PV 1
98 04616-119-00 HARNESS, B&S W / CAPACITOR 1
99 04111-052-00 COVER, FEEDGATE HANDLE 1
SPINNER MUST BE PACKED
INSIDE UNIT FOR SHIPPING.
DETAIL, FEEDGATE,
HANDLE ASSEMBLY
& DECALS
SEE CHAIN TENSION DETAIL
ON SHEET 2
ITEMS NOT SHOWN:
00122-073-01
INSTR. MANUAL
SEE B/M
04049-199-00
04540-003-00
04049-362-00
00107-662-00
00002-296-XX
04525-012-XX
00122-181-XX
25
43
53
60
84
92
94
96
EA. SIDE
97
DETAIL, IDLER ASSEMBLY
SCALE 0.250
7 8
4 19 21
4 19
6
5
81
12
WIPER MUST BE ADJUSTED TO
ADEQUATELY CLEAN CHAIN BARS
1
2
46
14 51
65
61 99
14 47 64
83
10 11
13 15 16
15 16
52
54
13 41
22
32 33
45
3
18 34
3 36
18 35 36
31
DECAL CENTERED ON
BACK OF HOPPER.
ZERK IN BEARING
TO AIM FORWARD
& UPWARD
63
4 19
52
29 30 38
18 44
DECAL TO BE CENTERED ON
BOTH SIDES OF ITEM #1
4 74 75
15 16 50 72
68
17
20
21
ISO VIEW
SCALE 0.100
16 56 57
73
48
13 15
58 59 62
63
55
49 82
D2
To Next Page
Loading...
