Monterey 208 SI - User Manual

128 pages

Save Page as PDF

To Next Page

To Next Page

Loading...

SPORT BOAT

OWNER’S MANUAL

180 FS

194 FS

208 SI

228 SI

248 LS

190 LS

214 FS

218 LS Cuddy

228 SI Cuddy

248 LS Cuddy

SPORT BOAT

OWNER’S MANUAL

180 FS

194 FS

208 SI

228 SI

248 LS

190 LS

214 FS

218 LS Cuddy

228 SI Cuddy

248 LS Cuddy

Table of Contents

Questions and Answers

R
robin45Aug 4, 2025
What to do if my Monterey 208 SI Boat engine will not crank?
- R
  rhondamaloneAug 4, 2025
  If your Monterey boat engine won't crank, several factors could be at play. Start by checking the connection of the engine stop switch and ensure the throttle/shift control is in neutral. Inspect the main circuit breaker and reset it if necessary. Clean any corrosion from the battery terminals and verify the battery isn't weak; recharge or replace it if needed. Finally, inspect and secure battery wiring connections.
B
Brandon SanchezAug 9, 2025
What to do if my Monterey Boat engine cranks but will not start?
- L
  lewiscassieAug 9, 2025
  If your Monterey boat engine cranks but won't start, begin by refilling the fuel tank. If that's not the issue, replace the fuel filter. As a next step, you should empty and clean the fuel system to eliminate contaminated fuel.
C
cory62Aug 13, 2025
Why is my Monterey 208 SI Boat having poor performance?
- S
  Shaun GrossAug 13, 2025
  Poor performance of your Monterey boat can stem from several issues. Begin by emptying and cleaning the fuel system to address potential fuel contamination. Ensure the load is evenly distributed within the boat. Adjust the engine trim as needed. Verify that you're using the appropriate propeller. Remove any excess water from the bilge.
J
John FranklinAug 17, 2025
How to improve gas mileage on a Monterey 208 SI?
- Z
  Zachary SimpsonAug 17, 2025
  To improve the gas mileage of your Monterey boat, start by cleaning or replacing the flame arrestor (stern drive). Then, adjust the engine trim. Also, clean the hull to remove any marine growth.
M
Mary JohnstonAug 22, 2025
What causes throttle/shifting problems in a Monterey 208 SI Boat?
- P
  Philip AllisonAug 22, 2025
  If you're experiencing throttle or shifting problems with your Monterey boat, a corroded or kinked cable may be the cause. Replace the corroded cable or straighten (or replace) the kinked cable.
R
Russell EricksonAug 26, 2025
Why is my Monterey 208 SI experiencing excessive vibration?
- R
  Roy ChavezAug 26, 2025
  Excessive vibration in your Monterey boat can be attributed to a damaged or fouled propeller. Inspect the propeller and repair or replace it as needed. Another potential cause is a bent propeller shaft, which should be straightened or replaced.
S
Susan HooperAug 30, 2025
How to troubleshoot electrical problems in a Monterey 208 SI?
- M
  Mark BennettAug 30, 2025
  If you're encountering electrical problems with your Monterey boat, check for a blown fuse or open circuit and replace the fuse or repair the circuit. Also, check and tighten any loose wiring connections. Finally, replace any defective switches or gauges.

Summary

Identification Numbers

Specifications

Instrument Console and Systems

Battery Switches and Fire Extinguishing

Operation of battery switches and automatic fire extinguishing systems.

Boating Safety

Required Safety Equipment

Federally required safety equipment for boats, including PFDs.

Emergencies and Hazards

Procedures for accidents, assistance, fires, and hazardous conditions.

Boating Under the Influence

Laws and risks associated with operating a boat while impaired.

Carbon Monoxide Hazards

Dangers of CO gas and importance of ventilation.

General Precautions and Environment

Basic Rules Of The Road

Right-of-Way Rules

Systems, Controls and Indicators

Ventilation and Fire Systems

Fuel, Oil, and Electrical Systems

Steering and Shift;Throttle Control

Operation of steering and shift/throttle controls.

Switches and Indicators

Operation Guidelines

Fueling Procedures

Procedures and safety precautions for fueling the boat.

Starting and Shifting

Steering, Stopping, and Docking

How to steer, stop, and dock the boat safely.

Boat Trim and Drive Angle

Adjusting trim for optimal performance and efficiency.

Getting Underway

Safety Checklist and Equipment

Essential pre-operation checks and required safety equipment.

Boarding and Boat Loading

Running and Maneuvering

Maneuvering Techniques

Towing and Anchoring

Performance Boating and Propellers

Operating at high performance and selecting/maintaining propellers.

Care and Maintenance

Repairs, Modifications, and Electrical

Corrosion Protection

Fuel and Steering System Maintenance

Troubleshooting Guide

Trouble Check Chart

Common boat problems and their possible causes for diagnosis.

Storage Procedures

Storage Preparation

Trailering Your Boat

Hitch and Safety Chains

Trailering Checklist

A checklist of pre-trip checks for safe boat trailering.

Backing, Launching, and Loading

Monterey Boats Limited Warranty

Hull Warranties

Lifetime and ten-year limited warranties for the fiberglass hull.

General Warranty and Exclusions

One-year general warranty, what is not covered, and warranty provisions.

Monterey 208 SI Specifications

General

Maximum Power	250 hp
Beam	8 ft 4 in
Deadrise	20 degrees
Seating Capacity	10 people
Length Overall (LOA)	20 ft 8 in

Related product manuals

Monterey 208 LS Cuddy

Preview: Monterey 295SY

Monterey 228 SIC

Monterey 248 LS CUDDY

Monterey 218 LS CUDDY

Monterey 220 Explorer Sport

Preview: Monterey Sport Cruiser 260SCR

Monterey Sport Cruiser 260SCR