Philips Saeco GranBaristo - User Manual

All parts of this document are the property of Saeco International Group.
All rights reserved.  is document and all the information herein is provided without liability deriving from any errors or omissions. Furthermore, no part may be reproduced, used or
collected, except where express authorisation has been provided in writing or through a contractual agreement.
Published by Saeco International Group
Subject to modi cation EN 4219 400 00022
Service
Service
Service
Service
Co ee Machine
GranBaristo
GranBaristo Avanti
2013-Sept.-02
Service
Service
Manual
Manual
Rev. 02 July 2014
TECHNICAL INFORMATION
Power supply and output: 240 V~ 50 Hz 1900W - 230 V~ 50/60 Hz 1900 W 120 V~ 60 Hz 1300 W
Temperature monitoring: (NTC) variable resistor sensor - transmits the value to the electronic card
Safety system: 2 thermostats at 190°C one shot
Co ee heat exchanger output: Stainless steel
for co ee, hot water and steam dispensing
(230 V~) 1900 W - (120 V~) 1300 W - (100 V~) 1100 W
Dimensions: W x H x D in mm: 210 x 360 x 460 mm
Stand-by power consumption < 0,5W
Weight: 13 kg
Water tank capacity: 1.7 l
Co ee bean hopper capacity: 270 g. of co ee beans
Dreg drawer capacity: 20
Heating time: Approx. 45 sec.
Water circuit  lling time: Approx. 15 sec Max. on  rst  lling cycle
Power consumption: During heating phase- approx. 5.6 A
Automatic dosage: Dose adjustment controlled by the electronic system
Material
Housing ABS/ABS+PMMA/METAL
Beans container ABS
Water tank SAN
Dreg drawer ABS

Summary

Introduction to Coffee Machine Service

General Safety Warnings

Crucial safety precautions for appliance repair.

Technical Specifications of the Coffee Machine

Machine Technical Specifications

Detailed technical data of the coffee machine.

Coffee Temperature Measurement Procedure

Milk Temperature Measurement Procedure

Piston Assembly Oil Leak Check

Operating Logic and System Functions

Granbaristo Water Circuit

Diagram and explanation of the machine's water circuit.

Milk Carafe System Operation

Explains the operation and components of the milk carafe system.

Coffee Brewing Cycle

Details the sequence of operations for brewing coffee.

Coffee Grinder Operation

Explains the operation and components of the coffee grinder.

Water Tank Level Detection

Descaling Process Request

Water Filter Functionality

Troubleshooting Coffee Machine Issues

Gran Baristo Avanti Test Mode

Guide to entering and using the test mode for Avanti model.

Gran Baristo Test Mode

Guide to entering and using the test mode for the base model.

Diagnostic Mode Overview

Explains the diagnostic mode menu structure and functions.

Machine Error Code Reference

Lists and describes error codes encountered by the machine.

Disassembly Procedures for Coffee Machine

Outer Casing Disassembly

Coffee Grinder Removal

Steps for removing and disassembling the coffee grinder.

Grinder Blade Adjustment and Removal

Grinder Adjustment Procedures

Solenoid and Drain Valve Removal

Piston Assembly Removal

Steps for removing the piston assembly.

Thermostat Removal Procedure

Coffee Pump Replacement

Flow Meter Removal

Brew Unit Gearmotor and Microswitch

Instructions for removing the gearmotor and microswitch.

CPU Board and Display Interface Removal

Water Circuit Diagram

Electrical Diagram

Philips Saeco GranBaristo Specifications

General

Coffee Strength Settings	5
Milk System	Integrated milk carafe
Weight	11.5 kg
Pump pressure	15 bar
Adjustable coffee volume	Yes
Removable brewing unit	Yes
Material boiler	Stainless steel
Voltage	230 V
Number of Coffee Varieties	18
Programmable	Yes
Type	Espresso machine
Water Tank Capacity	1.8 L
Color	Black