Home
Phoenix Contact
Wireless modules
RAD-868-IFS
Phoenix Contact RAD-868-IFS User Manual
5
of 1
of 1 rating
198 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
User manual
Radioline -
Wireless transmission system for
serial interfaces and I/O signals
2
Table of Contents
Rad-2400-Ifs
3
Table of Contents
5
Technical Data for the Wireless Modules
9
Rad-868-Ifs
9
Rad-Ai4-Ifs
16
For Your Safety
17
Intended Use
17
Installation Notes
18
Installation in Zone 2
19
Notes for Individual I/O Extension Modules
21
UL Notes (RAD-2400-IFS Only)
21
FCC and Industry Canada (RAD-2400-IFS Only)
22
Short Description
23
Wireless Modules
23
Firmware Versions
24
Rad-Pt100-4-Ifs
24
I/O Extension Modules
25
Rad-Ao4-Ifs
25
Installation
27
Wireless Module Structure
27
Basic Circuit Diagram
28
Mounting and Removal
28
Connecting Cables
30
Connecting the Power Supply
31
Serial Interfaces
32
Connecting the Antenna
35
Configuration and Startup
37
Default Settings of the Wireless Module
37
Operating Mode of the Wireless Module
39
Configuration Via CONFSTICK
42
Setting the Address of the Wireless Module Using the Thumbwheel
42
Copying Device Settings Via a Memory Stick
44
Configuration Via PSI-CONF Software
45
Diagnostics on the Wireless Module
51
Diagnostics Via PSI-CONF Software
56
Starting up I/O Extension Modules
59
Startup Time of the Wireless Station
61
Serial Data Mode
63
Frame-Based Data Transmission
65
Configuration Via PSI-CONF Software
67
Plc/Modbus RTU Mode
67
Addressing I/O Extension Modules
68
Watchdog
69
Modbus Function Codes
70
Module Type and Error Code Registers for I/O Extension Modules
71
Modbus Memory Map
72
Error Codes and Formats for Analog Input and Output Values
87
Description of I/O Extension Modules
89
RAD-AI4-IFS - Analog Extension Module with Four Inputs
89
RAD-PT100-4-IFS - Extension Module with Four Temperature Inputs
93
RAD-AO4-IFS - Analog Extension Module with Four Outputs
100
RAD-DI4-IFS - Digital Extension Module with Four Inputs
104
RAD-DI8-IFS - Digital Extension Module with Eight Inputs
108
RAD-DOR4-IFS - Digital Extension Module with Four Outputs
113
Figure 8-26 Basic Circuit Diagram for the RAD-DOR4-IFS
114
Figure 8-27 DIP Switches of the RAD-DOR4-IFS
114
Figure 8-28: Diagnostic Leds of the RAD-DOR4-IFS
115
RAD-DO8-IFS - Digital Extension Module with Eight Outputs
117
Figure 8-29 RAD-DO8-IFS Structure
118
Figure 8-30 Basic Circuit Diagram for the RAD-DO8-IFS
119
Figure 8-31 DIP Switches of the RAD-DO8-IFS
119
Figure 8-32 Diagnostics Leds of the RAD-DO8-IFS
120
RAD-DAIO6-IFS - Analog/Digital Extension Module with Six Channels
122
Figure 8-33 RAD-DAIO6-IFS Structure
123
Figure 8-34 Basic Circuit Diagram for the RAD-DAIO6-IFS
124
Figure 8-35 DIP Switches of the RAD-DAIO6-IFS
124
Figure 8-36 Diagnostic Leds of the RAD-DAIO6-IFS
125
Delay Time
127
Planning Wireless Systems
127
Pulse Transmission
129
Trusted Wireless 2.0
129
Figure 9-1 Penetration of Obstacles at Different Frequencies
131
Figure 9-2: Point-To-Point Connection, Star Network, Self-Healing Mesh Network
132
Figure 9-3: Distributed Network Management with Parent-Child Zones
132
Figure 9-4: RF Bands in the 2.4 Ghz Wireless System
133
Figure 9-5: RF Bands in the 868 Mhz Wireless System
133
RF Bands
133
Planning Wireless Paths
134
Practical Test
134
Selecting Antenna Cables and Antennas
135
Figure 9-6 Antenna Polarization
136
Installing Antennas
136
Figure 9-7: Decoupling Wireless Paths Due to Directivity and Different Polarization Levels
137
Figure 9-8 Outdoor Installation of Antennas
138
Level and Attenuation of Wireless Modules and Accessories
139
Free Space Path Loss
141
Figure 9-10 Diffraction on an Edge
143
Figure 9-11 Reflection on a Metal Surface
143
Figure 9-9 Dispersion on a Rough Surface
143
Propagation of Radio Waves
143
Figure 9-12 Reduction of Radio Waves When Penetrating a Wall
144
Figure 9-13 Angle of the Transmitter and Receiver
145
Figure 9-14 Radio Dead Spot
145
Figure 9-15 Wireless Path with Strong Wind
146
Fresnel Zone
146
Figure 9-16 Fresnel Zone
147
Range
148
Equivalent Isotropically Radiated Power (EIRP)
149
Figure 9-17 Free Space Path Loss
150
System Calculation in Free Space
150
Figure 9-18 Bush with an Attenuation of Approximately 15 Db
151
Figure 9-19 Forest with an Attenuation of Around 40 Db
151
Practical Examples
151
10 Detecting and Removing Errors
153
Figure 10-1 Loopback Test on an RS-232 Interface
159
Loopback Test During Serial Data Transmission
159
Figure 10-2 Settings in Hyperterminal
160
A Technical Appendix
161
Figure A-1 Omnidirectional Antenna, 2 Dbi
161
Typical Combinations of Antennas and Adapter Cables
161
Figure A-2: Omnidirectional Antenna with Protection against Vandalism, 3 Dbi
162
Figure A-3: Omnidirectional Antenna, 2.5 Dbi
163
Figure A-4: Omnidirectional Antenna, 6 Dbi, Without Surge Protection
164
Figure A-5: Omnidirectional Antenna, 6 Dbi, with Surge Protection
165
Figure A-6: Directional Antenna, 9 Dbi, with Outdoor Surge Protection
167
Figure A-7: Parabolic Antenna, 19 Dbi, with Outdoor Surge Protection
168
Figure A-8: Omnidirectional Antenna, 4 Dbi, with Surge Protection
169
Figure A-9: Directional Antenna, with Surge Protection
170
Figure A-10: Directional Antennas, 8 Dbi, with 2-Way Outdoor Antenna Splitter
172
Figure A-11: Antenna Installation in Zone 2
173
A 2 Control Box for Wireless Systems
175
Figure A-12: Control Box with Wireless System
175
A 3 PROFIBUS Connections
176
Figure A-13 Point-To-Point Connection with PROFIBUS
176
Figure A-14 Star Structure with PROFIBUS, up to 10 Slaves
177
A 4 Configuration
178
Figure A-15 Star Structure with Several Wired PROFIBUS Slaves Downstream of the Wireless Path
178
Figure A-16 PSI-CONF Software
179
Figure A-17 PSI-CONF Software: "Device Selection
179
Figure A-18 PSI-CONF Software: "Network Project
180
Figure A-19: PSI-CONF Software: "Wizard, Step 1
180
Figure A-20: PSI-CONF Software: "Wizard, Step 2
181
Figure A-21: PSI-CONF Software: "Wizard, Step 3
181
Figure A-22: PSI-CONF Software: "Wizard, Step 4
182
Figure A-23: PSI-CONF Software: "Wizard, Step 5
182
Figure A-24: PSI-CONF Software: "Wizard, Step 6
183
Figure A-25 PSI-CONF Software: "Network Settings
183
Figure A-26 SIMATIC ® Manager
185
Figure A-27 "Netpro" Window
185
Figure A-28 "Network Settings" Tab, Transmission Rate
186
Figure A-29 "Cables" Tab
186
Figure A-30 "Network Settings" Tab, Profile
186
Figure A-31 "Bus Parameters" Tab
187
Figure A-32 "Bus Parameters" Tab, Response Monitoring
187
Figure A-33 "Properties - DP" Tab
188
B 1 List of Figures
189
B 2 List of Tables
193
B 3 Index
195
Appendixes
189
Other manuals for Phoenix Contact RAD-868-IFS
Installation Notes
6 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Phoenix Contact RAD-868-IFS and is the answer not in the manual?
Ask a question
Phoenix Contact RAD-868-IFS Specifications
General
Brand
Phoenix Contact
Model
RAD-868-IFS
Category
Wireless modules
Language
English
Related product manuals
MOTR-9 RAD-ISM-900-EN-BD
122 pages
Need help?
General
To Next Page
