Phoenix TL600 - Section 3 - Operation; General Operation and Preparation

PHOENIX METAL PRODUCTS, INC
TL600/TL700 LAVATORY SERVICE TRUCK
20
MAY 2018
CHAPTER 1
SECTION 3 - OPERATION
GENERAL
OPERATION OF THE PHOENIX TL600 IS FAIRLY SIMPLE. ALL CONTROLS ARE CLEARLY MARKED
AND SELF EXPLANATORY. THE FOLLOWING PROCEDURES ARE RECOMMENDED FOR THE
OPERATION OF THIS EQUIPMENT. YOUR ORGANIZATION MAY HAVE A MORE DETAILED OR
DIFFERENT PROCEDURE FOR OPERATION OF THIS EQUIPMENT. PLEASE CHECK WITH YOUR
SUPERVISORS BEFORE OPERATING THIS EQUIPMENT.
THERE ARE NO INSTRUCTIONS FOR THE OPERATION OF THE TRUCK PORTION OF THIS VEHICLE
SINCE THIS IS A COMMERCIAL VEHICLE AND SHOULD NOT PRESENT ANY PROBLEMS. REFER TO
THE TRUCK OWNERS MANUAL FOR OPERATION OF THE TRUCK
PREPARATION FOR USE
BEFORE EACH DAY’S USE, THE FOLLOWING INSPECTION/CHECKS SHOULD BE
PERFORMED.
WALK AROUND THE UNIT AND MAKE A VISUAL INSPECTION PAYING PARTICULAR
ATTENTION TO THE FOLLOWING:
(1) CHECK GENERAL CONDITION OF TRUCK CHASSIS, BODY AND THE CONDITION
OF THE RUBBER BUMPERS ON THE PLATFORM AND HAND RAILS.
(2) NOTE THE CONDITIONS OF THE TIRES AND CHECK FOR PROPER INFLATION.
RECOMMENDED PRESSURE SHOULD BE 70 POUNDS IN THE FRONT AND 80
POUNDS IN THE REAR.
(3) THE FOLLOWING FLUID LEVELS CAN BE CHECK WITHOUT RAISING THE
CAB - (FIGURE # 3) , BRAKE, WINDSHIELD WASHING FLUID AND RADIATOR
RESERVOIR.
(4) RAISE CAB AND CHECK ENGINE OIL, POWER STEERING, TRANSMISSION
CONDITION AND TENSION OF ALL V BELTS. (FIGURE # 3A).
NOTE:
TL600/700 ISUZU MODEL
IF THE OPTIONAL GRILL GUARD IS INSTALLED, IT MUST BE FULLY
LOWERED BEFORE RAISING THE CAB. DAMAGE TO THE CAB WILL OCCUR IF
THE GRILL GUARD IS NOT LOWERED BEFORE UNLATCHING THE CAB.
Property of American Airlines