10
Service &
Maintenance
Monthly Inspection Check List
Lift no:
Vehicle Reg:
Engineer’s Name: Date:
Customer Details:
Address, Contact:
Tel Number:
OK
1
Check for obvious signs of damage and replace defective parts where
necessary.
2 Check the operation and stowing of the lift.
3 Check rear Roll-Off Ramp operation and lubricate as necessary.
4
Check Platform alignment (pin location), adjust Platform Knuckles as
necessary.
5
Ensure the Handset control is working correctly and there are no signs of
damage.
6
Check lift ‘vertical’ stowing position. Lift should be clear of rear doors and
only lower when the down button is depressed
7
Check Platform ‘horizontal’ position. Each side of the lift platform can be
adjusted independently if required.
8
Check Power Pack oil reservoir (when the lift platform is completely
stowed) if necessary, top up slowly with PLS Blue oil ONLY to within
9
When cleaning the vehicle, wash the working platform of the lift. For best
results use a stiff brush and soapy water. Replace any missing 3M
surface tape as necessary.
10 Lubricate all required parts.
11 Check the condition/ correct operation of the Platform Knuckles.
12 Ensure the Bridge plate and linkages are working correctly.
10.5 Monthly Inspections Access™ EA & Access™ EAB
IF IN DOUBT, CONTACT THE MANUFACTURER
Regular lift maintenance is recommended at MONTHLY intervals by the lift
operating company. The working life of your lift will be greatly prolonged if these
steps are adhered to.
10.5 Monthly Inspections Access™ EA & Access™ EAB
To Next Page
Loading...
Need help?
General