Polaris FS Classic - Page 92

89
MAINTENANCE
Periodic Maintenance Interval Table
D =Perform
" = Replace
DAILY
or
PRE-
RIDE
INITIALLY
mi
(km)
YEARLY
or EVERY
mi
(km)
Item Pg Instructio n s
(see referenced pag es)
150
(240)
500
(800)
1500
(2400)
Coolant Hoses
--
Inspect, replace if worn or damaged
D D D
Heat Exchangers
--
Inspect, replace if damaged
D D D
Throttle Lever 65
81
D D D
Fuel Lines
103 Inspect, replace if worn or damaged
D D D
Battery
Clean terminals, test voltage
D D D
Track Alignment
124
Verify alignment, adjust as needed
D D D
Track Tension
122
Verify tension, adjust as needed
D D D
Handlebars
--
Verify alignment, adjust as needed
D D D
Drive Chain
110
Verify tension, adjust as needed
EVERY
Rear Track Shock
(M-10)
-- Inspect covers and caps for wear or
damage, replace as needed
EVERY
Gearcase Oil 100 Check at 500 mi. (800 km), change
every 1000 mi. (1600 km)
D
EVERY
1000 (1600)
Rear Suspension 98 Lubricate pivot shafts
(more often in wet snow conditions)
D D
Bearings 131 Lubricate drive shaft and jackshaft
bearings
D D
Throttle Cable
98
Lubricate
D D
Clutches 116 Verify offset alignment, inspect for
wear, residue, loose bushings,
see your dealer for all service
D D
Drive Belt 117 Check tension and condition,
replace if worn or damaged
D D
Air Filter 104 Inspect for oil and dirt, replace as
needed
D D
Oil/Filter Change
94
Replace oil and filter
" "