Polaris Sportsman 570 EPS - Page 102

100
MAINTENANCE
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
Ź Air filter, main
element
- Weekly - Inspect; replace as needed
Recoil housing - Weekly - Drain water as needed,
check often if operating in wet
conditions
Ź
D
Brake pad wear 10 H Monthly 100 (160) Inspect periodically
Battery 20 H Monthly 200 (320) Check terminals; clean; test
Fuel System 20 H Monthly - Inspect; cycle key to
pressurize fuel pump; check
lines and fittings for leaks and
abrasion
Ź Engine breather 25 H Monthly 250 (400) Inspect hose (and valve, if
equipped); replace if needed
Ź Engine oil change 25 H 1 M - Break-in oil and filter change
Ź Demand drive fluid
(extreme use)
25 H 1 M 250 (400) Change fluid every 25 hours
if ADC is subjected to
extreme use. See page 109.
Ź Demand drive fluid 25 H 1 M 250 (400) Break-in oil level check
Ź Rear gearcase oil 25 H 1 M 250 (400) Break-in oil level check
Ź Transmission oil 25 H 1 M 250 (400) Break-in oil level check
Ź General lubrication 50 H 3 M 500 (800) Lubricate all fittings, pivots,
cables, etc.
D Throttle Cable/
Release Switch
50 H 6 M 500 (800) Inspect; adjust; lubricate;
replace if necessary
Throttle Body
Intake Duct
50 H 6 M 500 (800) Inspect duct for proper
sealing/air leaks
Drive belt 50 H 6 M 500 (800) Inspect; adjust; replace as
needed
Cooling system 50 H 6 M 1000 (1600) Inspect coolant strength
seasonally; pressure test
system yearly
Ź Engine oil change 100 H 6 M 1000 (1600) Change the oil and filter
Ź Oil lines and
fasteners
100 H 6 M 1000 (1600) Inspect for leaks and loose
fittings