Need help?Do you have a question about the Polini Thor 200 HF and is the answer not in the manual?
Details on warranty validity, coverage, obligations, and limitations.
Specifies recommended fuel type, octane rating, and oil mixture ratio.
Safety measures for handling flammable petrol.
Procedure for starting the engine with a Walbro carburetor.
Procedure for starting the engine with a bowl carburetor.
Starting procedure for engines with an electric starter.
Important safety checks before and during engine starting.
Steps to properly break in the engine for reliability.
How to safely turn off the engine.
Guidelines for cleaning the engine safely.
How to check and adjust carburetion using spark plug color.
Safety precautions and procedures for transporting the engine.
Specific instructions for transporting engines with a bowl carburetor.
Specific instructions for transporting engines with a Walbro carburetor.
Overview of routine maintenance tasks and importance of qualified personnel.
How to remove, clean, and replace the air filter.
Procedure for checking the gear oil level.
Steps for changing the gear oil.
Guide to replacing the starter rope.
Advice on throttle usage and engine RPM management during flight.
Optimal operating temperature range and factors affecting it.
Instructions for mounting the engine onto the aircraft frame.
Specific installation steps for engines with electric starter.
Connecting the fuel system components.
Installing and connecting the throttle control.
Step-by-step guide for installing the propeller and flange.
Connecting the optional voltage regulator.
Table detailing maintenance tasks based on usage hours.
Specifications for tightening engine bolts and screws.
General torque specifications for common bolt sizes.
Common engine problems, their causes, and solutions.
General| Cooling System | Air-cooled |
|---|---|
| Fuel System | Carburetor |
| Bore | 66 mm |
| Compression Ratio | 12:1 |
| Engine Type | Single cylinder 2 stroke |
| Carburetor | Dell'Orto |
| Ignition System | Electronic |
| Starter | Kick start |
| Lubrication | Premix |
To Next Page
