Poulan Pro PB18542LT User Manual (English)

Questions and Answers:

M
Michael ShieldsAug 17, 2025
How to fix Poulan Pro Lawn Mower that will not start?
- C
  clarksandraAug 18, 2025
  If your Poulan Pro Lawn Mower won't start, possible causes include being out of fuel (fill the fuel tank), improper choking (consult the Operation section for starting procedures), a flooded engine (wait a few minutes before restarting), a bad spark plug (replace it), a dirty air filter (clean or replace it), or a dirty fuel filter (replace it). Other potential issues are water in the fuel (empty the tank and carburetor, refill with fresh gasoline, and replace the fuel filter), loose or damaged wiring (check all wiring), a carburetor out of adjustment (see the Service Adjustments section), or engine valves out of adjustment (contact an authorized service center).
H
hoganlorettaAug 20, 2025
How to troubleshoot hard starting Poulan Pro Lawn Mower?
- V
  vancejonathanAug 20, 2025
  If your Poulan Pro Lawn Mower is hard to start, consider these possible causes: * A dirty air filter (clean or replace it). * A bad spark plug (replace it). * A weak or dead battery (recharge or replace it). * A dirty fuel filter (replace it). * Stale or dirty fuel (empty the tank and refill with fresh, clean gasoline). * Loose or damaged wiring (check all wiring). * Carburetor out of adjustment (see the Service Adjustments section). * Engine valves out of adjustment (contact an authorized service center).
C
Charles WilliamsAug 23, 2025
What to do if Poulan Pro Lawn Mower engine clicks but will not start?
- B
  basskevinAug 23, 2025
  If the engine of your Poulan Pro Lawn Mower clicks but won't start, it could be due to a weak or dead battery (recharge or replace it), corroded battery terminals (clean them), loose or damaged wiring (check all wiring), or a faulty solenoid or starter (check or replace them).
M
Michael MeyerAug 26, 2025
Why Poulan Pro Lawn Mower engine will not turn over?
- C
  Christopher MorrisAug 26, 2025
  If your Poulan Pro Lawn Mower engine will not turn over, ensure the clutch/brake pedal is depressed. Also, disengage the attachment clutch. Other potential causes include a weak or dead battery (recharge or replace it), a blown fuse (replace it), corroded battery terminals (clean them), loose or damaged wiring (check all wiring), a faulty ignition switch (check or replace it), a faulty solenoid or starter (check or replace them). For faulty operator presence switch(es), contact an authorized service center.
J
Jordan HoltAug 27, 2025
What causes Poulan Pro Lawn Mower blades will not rotate?
- M
  michaelwagnerAug 27, 2025
  If your Poulan Pro Lawn Mower blades won't rotate, check for an obstruction in the clutch mechanism and remove it. Also, inspect the mower drive belt for wear or damage and replace if necessary. Additionally, check the idler pulley and blade mandrel for freezing and replace if needed.
T
tina07Aug 30, 2025
Why Poulan Pro Lawn Mower has poor cut - uneven?
- B
  Brian ObrienAug 30, 2025
  If your Poulan Pro Lawn Mower provides a poor and uneven cut, replace the blade or tighten the blade bolt if the blade is worn, bent, or loose. Level the mower deck. Clean the underside of the mower housing to remove any buildup of grass, leaves, and trash. Replace the blade mandrel if it's bent. Clean around the mandrels to open vent holes if they are clogged.
Z
zmendezSep 4, 2025
How to improve Poulan Pro Lawn Mower poor grass discharge?
- K
  kelli63Sep 4, 2025
  If your Poulan Pro Lawn Mower has poor grass discharge, ensure the throttle control is in the “FAST” position and shift to a slower speed if you're traveling too fast. Allow the grass to dry before mowing if it's wet. Also, level the mower deck and check the tires for proper air pressure. Other possible causes include a worn, bent, or loose blade (replace/sharpen and tighten), buildup of grass, leaves, and trash under the mower (clean the underside), a worn mower drive belt (replace it), improperly installed blades (reinstall sharp edge down), improper blades used (replace with correct blades), or clogged mower deck vent holes (clean around mandrels).
M
Mark CrosbySep 7, 2025
How to reduce excessive vibration in Poulan Pro Lawn Mower?
- T
  Timothy SharpSep 7, 2025
  If your Poulan Pro Lawn Mower has excessive vibration, replace the blade or tighten the blade bolt if the blade is worn, bent, or loose. Replace the blade mandrel if it's bent. Also, tighten any loose parts and replace any damaged parts.
J
Justin SuttonSep 9, 2025
How to fix Poulan Pro Lawn Mower headlight(s) not working?
- M
  Meagan GarzaSep 9, 2025
  If the headlight(s) on your Poulan Pro Lawn Mower aren't working, first, ensure the light switch is “ON.” If not, turn it on. If the bulb(s) or lamp(s) are burned out, replace them. Check or replace the light switch if it's faulty. Inspect the wiring and connections for looseness or damage. Finally, replace the fuse if it's blown.
B
Brent WareSep 12, 2025
What to do if Poulan Pro Lawn Mower engine dies when tractor is shifted into reverse?
- P
  Patrick MccarthySep 12, 2025
  If your Poulan Pro Lawn Mower engine dies when shifted into reverse, ensure the Reverse Operation System (ROS) is turned "ON" while the mower or other attachment is engaged by turning the ignition key to the ROS "ON" position.

Poulan Pro PB18542LT Specifications

General

Brand	Poulan Pro
Model	PB18542LT
Category	Lawn tractor
Language	English

Summary

SAFETY RULES

Important Safety Instructions

Key safety warnings about severe injury or death from machine operation.

Preventing Accidental Starting

Instructions on disconnecting spark plug wire before servicing the tractor.

Safe Towing Practices

Guidelines for towing attachments, speed limits on slopes, and load capacity.

California Proposition 65 Warnings

Warnings about chemicals known to cause cancer or birth defects.

General Operation Guidelines

Basic rules for operating the tractor safely, including clearing the area and adult operation.

Slope Operation Safety

Precautions for operating the tractor on slopes to prevent tip-overs and loss of control.

Children Safety

Rules to ensure children's safety around the operating tractor.

Towing Guidelines

Guidelines for safe towing of equipment and weight limits.

Safe Gasoline Handling

Precautions for safe handling and storage of gasoline.

General Service Recommendations

Maintenance tips for safe operation, checking parts, and general safety.

PRODUCT SPECIFICATIONS

Fuel and Oil Specifications

Details on fuel type, capacity, and engine oil specifications.

Spark Plug and Speed

Information on spark plug type and tractor ground speeds.

Battery and Charging System

Specifications for the tractor's battery and charging system.

Blade Torque Specification

Recommended torque specification for blade bolts.

CUSTOMER RESPONSIBILITIES

Adhere to Safety Rules

Emphasizes reading and following all safety instructions.

Follow Maintenance Schedule

Advises following a regular schedule for maintenance and care.

Refer to Manual Sections

Refers to specific sections for maintenance and storage guidance.

CONTENTS OF HARDWARE PACK

Steering Wheel Components

Lists parts included for the steering wheel assembly.

Seat Components

Lists parts included for the seat assembly.

Other Included Items

Lists other items like keys, oil drain tube, and slope sheet.

ASSEMBLY

Tools Required for Assembly

Lists necessary tools for assembling the tractor.

Unpack Tractor Carton

Instructions for unpacking the tractor carton and removing parts.

Prepare for Skid Removal

Steps to prepare the tractor before taking it off the shipping skid.

Install Steering Wheel (Fig. 1)

Step-by-step guide to assemble the steering wheel.

Install Seat (Fig. 2)

Instructions for installing and adjusting the tractor seat.

Check Battery Status (Fig. 3)

Procedure for checking the tractor battery status.

Remove Tractor from Skid

Steps to safely remove the tractor from its shipping skid.

Check Tire Pressure

Importance and procedure for checking tire pressure.

Check Mower Deck Levelness

Guidance on checking mower deck levelness for optimal cutting.

Check Belt Routing

Verifying correct routing of mower and drive belts.

Check Brake System

Instructions to check the proper functioning of the brake system.

Pre-Operation Checklist

A checklist of items to review before operating the tractor for the first time.

OPERATION

Understand Tractor Symbols

Explains various symbols that may appear on the tractor or in the manual.

Safety Alert Symbol Definitions

Defines DANGER, WARNING, and CAUTION symbols and their meanings.

Identify Tractor Controls

Encourages familiarization with tractor controls and adjustments.

Control Functions Explained (Fig. 4)

Identifies and describes the function of various tractor controls (A-J).

Tractor Operation Basics

General guidance on operating the tractor.

Set Parking Brake (Fig. 5)

Step-by-step instructions for setting the parking brake.

Stop Tractor and Blades (Fig. 6)

Procedures for stopping mower blades and the tractor's ground drive.

Use Throttle Control (Fig. 7)

Guidance on using the throttle control for engine speed.

Forward and Backward Movement

How to control the tractor's movement using the gearshift lever.

Adjust Mower Cutting Height (Fig. 8)

How to adjust the mower deck cutting height using the lift lever.

Reverse Operation System (ROS)

Explanation of the ROS and how to use it safely.

Using the Reverse Operation System

Detailed steps for engaging and disengaging the ROS.

Adjust Gauge Wheels (Fig. 9)

Instructions for adjusting mower gauge wheels for proper deck leveling.

Operate Mower (Fig. 10)

Steps for operating the mower, including blade engagement.

Stop Mower Blades

How to disengage the mower blades.

Operate on Hills Safely

Crucial safety warnings and procedures for operating on slopes.

Transport Tractor Safely

Instructions for safely transporting the tractor.

Towing Attachments

Guidelines for towing accessories.

Pre-Start Engine Checks

Checks to perform before starting the engine, including oil and fuel.

Add Gasoline Safely

How to properly add fuel to the tractor's tank.

Start Engine Procedures (Fig. 4)

Procedures for starting the engine in warm and cold weather.

Mowing Tips and Best Practices

Advice for optimal mowing performance and lawn care.

MAINTENANCE

Maintenance Schedule Overview

A table outlining maintenance tasks and their recommended frequency.

General Maintenance Recommendations

Advice on warranty, periodic adjustments, and annual maintenance tasks.

Before Each Use Checks

Daily checks to perform before operating the tractor.

Lubrication Guide

Diagram and notes on lubrication points and types of grease.

Tractor Maintenance Safety

General safety rules for performing maintenance.

Check and Adjust Brake

How to check and adjust the tractor's brake system.

Tire Maintenance

Maintaining proper tire pressure and avoiding tire damage.

Safety System Checks (Fig. 12)

Checking the functionality of safety systems.

Mower Blade Care

Importance of sharp blades and precautions when replacing them.

Remove Mower Blades (Fig. 13)

Step-by-step guide for removing mower blades.

Battery Care and Charging

How to maintain and charge the tractor battery.

Clean Battery Terminals

Procedure for cleaning battery terminals to prevent corrosion.

V-Belt Inspection

Inspection and replacement of V-belts.

Transaxle Cooling Maintenance

Keeping the transaxle free from debris for cooling.

Engine Oil Lubrication

Selecting and using the correct engine oil based on temperature.

Change Engine Oil (Figs. 14 & 15)

Detailed instructions for changing the engine oil.

Clean Air Screen

How to clean the air screen to prevent engine overheating.

Air Filter Service

Importance of servicing the air filter for engine performance.

Muffler Inspection

Inspecting and replacing the muffler and spark arrester.

Spark Plug Replacement

When to replace spark plugs for optimal engine operation.

Replace Fuel Filter (Fig. 16)

How to replace the in-line fuel filter.

General Cleaning Procedures

General cleaning tips for the tractor and its components.

SERVICE AND ADJUSTMENTS

Safety Precautions for Service

Critical safety precautions before performing any service or adjustments.

Remove Mower Deck (Fig. 17)

Step-by-step instructions for removing the mower deck.

Install Mower Deck (Figs. 17-22)

Instructions for installing the mower deck onto the tractor.

Attach Mower Side Suspension Arms

How to attach the mower's side suspension arms to the tractor chassis.

Attach Rear Lift Links

Instructions for connecting the rear lift links of the mower deck.

Attach Front Link

How to connect the front link assembly of the mower deck.

Check Belt Routing

Important check for proper belt routing in mower pulley grooves.

Level Mower Deck

Procedures for leveling the mower deck for optimal cutting results.

Visual Deck Side-to-Side Adjustment (Fig. 23)

How to visually adjust mower deck side-to-side levelness.

Precision Deck Side-to-Side Adjustment (Fig. 24)

Method for precise side-to-side adjustment of the mower deck.

Deck Front-to-Back Adjustment (Figs. 25 & 26)

How to adjust the mower deck for proper front-to-back pitch.

Replace Mower Blade Drive Belt (Fig. 27)

Instructions for replacing the mower blade drive belt.

Check Brake Function

Procedure to check if the tractor brake needs adjustment or service.

Replace Motion Drive Belt (Fig. 28)

Instructions for replacing the motion drive belt.

Adjust Transaxle Gear Shift Lever (Fig. 29)

How to adjust the gear shift lever for neutral position.

Adjust Steering Wheel Alignment

Steps for correcting steering wheel alignment.

Front Wheel Toe-In/Camber

Information that front wheel toe-in and camber are not adjustable.

Remove Wheel for Repairs (Fig. 30)

How to remove a wheel for repair or maintenance.

Start Engine with Weak Battery (Fig. 31)

Procedure for jump-starting the tractor with a weak battery.

Replace Battery (Figs. 32 & 33)

Detailed instructions for replacing the tractor battery.

Replace Fuse

How to replace the tractor's fuse.

Remove Hood and Grill (Fig. 34)

Steps for removing the tractor's hood and grill.

Engine Adjustments

Section covering engine adjustments.

Adjust Throttle Control Cable

Adjusting the throttle control cable.

Adjust Choke Control

Adjusting the choke control.

Adjust Carburetor

Information on carburetor adjustability and service.

STORAGE

Prepare Fuel System for Storage

Procedures to prepare the fuel system for storage to prevent gum deposits.

Engine Oil for Storage

Instructions for draining and replacing engine oil for storage.

Protect Engine Cylinders

Steps to protect the engine cylinders during storage.

General Storage Tips

General tips for storing the tractor and its components.

TROUBLESHOOTING POINTS

Engine Will Not Start

Common causes and corrections for engine not starting.

Engine Hard to Start

Troubleshooting steps for an engine that is difficult to start.

Engine Will Not Turn Over

Diagnosing and fixing issues where the engine doesn't crank.

Engine Clicks, Won't Start

Troubleshooting for clicking sounds without engine start.

Loss of Engine Power

Identifying causes and solutions for reduced engine power.

Excessive Vibration

Troubleshooting excessive vibration issues.

Engine Stops in Reverse

Causes and fixes for the engine stopping when shifting to reverse.

Engine Runs After Leaving Seat

Troubleshooting faulty operator presence control system.

Uneven Grass Cut

Solutions for uneven grass cutting results.

Mower Blades Not Rotating

Diagnosing why mower blades are not turning.

Poor Grass Discharge

Addressing issues with grass discharge.

Headlights Not Working

Troubleshooting non-functional headlights.

Battery Not Charging

Identifying reasons for battery not charging.

Engine Backfires on Shutdown

Correcting engine backfire when shutting off.

LIMITED WARRANTY

Manufacturer's Express Warranty

Details of the product warranty, coverage, and limitations.

Battery Specific Warranty

Specific warranty terms for the tractor's battery.

Rental/Commercial Use Warranty

Warranty period for products used for rental or commercial purposes.

Warranty Exclusions List

Items and conditions not covered by the warranty.

How to Make a Warranty Claim

How to submit a warranty claim and contact information.

SUGGESTED GUIDE FOR SLOPING OPERATIONS

Fold Page for Slope Measurement

Instructions to fold the page for slope measurement.

Measure Hill Slope Angle

Steps to measure hill slope angle using the folded page.

Slope Operation Safety Warning

Crucial safety warning about operating on slopes up to 15 degrees.

PARTS AND SERVICE

Contact Authorized Distributor

Information on how to contact a distributor for parts and service.

Information for Replacement Parts

Details needed when ordering replacement parts.

Technical Assistance Contact

Contact information for technical support.

Obtain Parts Manual Online

How to obtain a parts manual from the website.

Product Improvement Philosophy

Company philosophy on product improvement and contacting dealers for differences.

IMPORTANT MANUAL

Do Not Discard Manual

Reminder not to discard the owner's manual.

Review Safety Instructions

Emphasizes reading and following safety warnings and instructions.

Related product manuals

Poulan Pro PB18542LT User Manual

Table of Contents

Questions and Answers:

Poulan Pro PB18542LT Specifications

Summary

SAFETY RULES

Important Safety Instructions

Preventing Accidental Starting

Safe Towing Practices

California Proposition 65 Warnings

General Operation Guidelines

Slope Operation Safety

Children Safety

Towing Guidelines

Safe Gasoline Handling

General Service Recommendations

PRODUCT SPECIFICATIONS

Fuel and Oil Specifications

Spark Plug and Speed

Battery and Charging System

Blade Torque Specification

CUSTOMER RESPONSIBILITIES

Adhere to Safety Rules

Follow Maintenance Schedule

Refer to Manual Sections

CONTENTS OF HARDWARE PACK

Steering Wheel Components

Seat Components

Other Included Items

ASSEMBLY

Tools Required for Assembly

Unpack Tractor Carton

Prepare for Skid Removal

Install Steering Wheel (Fig. 1)

Install Seat (Fig. 2)

Check Battery Status (Fig. 3)

Remove Tractor from Skid

Check Tire Pressure

Check Mower Deck Levelness

Check Belt Routing

Check Brake System

Pre-Operation Checklist

OPERATION

Understand Tractor Symbols

Safety Alert Symbol Definitions

Identify Tractor Controls

Control Functions Explained (Fig. 4)

Tractor Operation Basics

Set Parking Brake (Fig. 5)

Stop Tractor and Blades (Fig. 6)

Use Throttle Control (Fig. 7)

Forward and Backward Movement

Adjust Mower Cutting Height (Fig. 8)

Reverse Operation System (ROS)

Using the Reverse Operation System

Adjust Gauge Wheels (Fig. 9)

Operate Mower (Fig. 10)

Stop Mower Blades

Operate on Hills Safely

Transport Tractor Safely

Towing Attachments

Pre-Start Engine Checks

Add Gasoline Safely

Start Engine Procedures (Fig. 4)

Mowing Tips and Best Practices

MAINTENANCE

Maintenance Schedule Overview

General Maintenance Recommendations

Before Each Use Checks

Lubrication Guide

Tractor Maintenance Safety

Check and Adjust Brake

Tire Maintenance

Safety System Checks (Fig. 12)

Mower Blade Care

Remove Mower Blades (Fig. 13)

Battery Care and Charging

Clean Battery Terminals

V-Belt Inspection

Transaxle Cooling Maintenance