EasyManua.ls Logo

Powermate PWFT14022 - User Manual

Powermate PWFT14022
72 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Look Inside for:
Page
Safety Definitions 1
Important Safety Information 2-4
Specifications 5
Features 5
Assembly 6-7
Engine Preparation 8-9
Operation 10-11
Maintenance 12-18
Technical Service 18
Troubleshooting 19
Warranty 20-23
French 24
Español 48
10/24/2012 Printed in China A202378
Operator’s Manual
FIELD TRIMMER
139 cc, 4 Cycle
IMPORTANT:
Thank you for purchasing this Powermate® Field Trimmer.
This manual provides complete instructions for safely operating and maintaining your Trimmer. Read and save these
instructions. Refer to this manual each time before using your Trimmer.
Record the following for future reference:
Mfg. Date Code: ______________________
Date of Purchase: Attach a copy of your sales receipt.
Consumer Toll Free Number: 1-800-737-2112
Refer to the website for electronic manual and parts book.
www.powermate.com
KEEP THIS MANUAL FOR FUTURE REFERENCE
MODEL Nos. PWFT14022
If you have a question or problem...
CALL TOLL FREE: 1-800-737-2112
WARNING
CALIFORNIA PROPOSITION 65 WARNING
Engine exhaust, some of its constituents, and certain product components contain or emit chemicals known to the State
of California to cause cancer and birth defects or other reproductive harm.

Table of Contents

Questions and Answers

  • I
    Isaac BeckAug 3, 2025
    What to do if Powermate Trimmer engine runs rough and smokes?
    • G
      gwatersAug 4, 2025
      If your Powermate Trimmer engine is running rough, smoking excessively, erratically, or cannot maintain full speed, consider the following: * Add engine oil if there is none. * Check the engine oil level and add or drain oil as necessary. * Remove, inspect, and replace the spark plug if it's fouled. * Remove and clean the air filter if it's clogged. * Take the unit to an authorized service center for carburetor adjustment. * Drain the fuel tank, clean it, and fill it with fresh fuel if it's contaminated.
  • L
    Lee JohnsonAug 8, 2025
    What causes excessive vibration and noise in Powermate Trimmer?
    • M
      Maureen MatthewsAug 8, 2025
      Excessive vibration or noise in your Powermate Trimmer can be due to: 1. Loose parts: Tighten all fasteners. 2. Unequal trimmer line length: Replace with trimmer lines of equal length. 3. Engine problems: Refer to engine solutions.
  • L
    Leslie WilliamsAug 12, 2025
    What to do if Powermate PWFT14022 engine overheats?
    • R
      Russell LoganAug 12, 2025
      If your Powermate Trimmer engine is overheating: 1. Check the cooling system: Remove any debris from the recoil starter cover and cooling fins. 2. Also, the overheating can be related to other engine problems, so refer to the engine solutions.
  • D
    Dana MortonAug 17, 2025
    Why Powermate PWFT14022 head does not retain line?
    • S
      Sean WintersAug 17, 2025
      If the trimmer head on your Powermate Trimmer isn't retaining the line, it could be due to these reasons: * The trimmer line is not properly attached: Follow the instructions in the maintenance section for attaching the line. * The line retainer is broken: Have the trimmer head assembly replaced. * The trimmer line is not the correct size: Use a 0.155 in. (4 mm) trimmer line. * The trimmer line is too brittle: Use a trimmer line that has been soaking in water.
  • D
    Dakota WhiteAug 21, 2025
    Why Powermate PWFT14022 Trimmer has poor trimming performance?
    • N
      nguyenlindaAug 21, 2025
      Poor trimming performance in your Powermate Trimmer can be caused by: 1. Trimmer line being too short: Replace with the correct length trimmer line (22 inches). 2. Engine problems: Refer to engine solutions.
  • C
    Cynthia MillerAug 26, 2025
    What to do if Powermate PWFT14022 engine will not stop?
    • M
      meredithhallAug 26, 2025
      If your Powermate Trimmer engine will not stop, inspect the control lever and wire. Replace if necessary.
  • D
    David WashingtonOct 29, 2025
    Why is my Powermate Trimmer engine difficult to start?
    • D
      Donna WilliamsOct 29, 2025
      There are several reasons why your Powermate Trimmer engine might be hard to start: * The unit might be out of fuel: add fresh fuel. * The engine may not be primed: press the primer bulb three times, waiting two seconds between each push. * The engine could be flooded: wait a few minutes before attempting to start it again. * The spark plug wire might be disconnected: attach the spark plug wire to the spark plug. * There may be a defective throttle control lever or wire: inspect the lever and wire, and replace if necessary. * The spark plug could be fouled: remove and inspect the spark plug, replacing it if needed. * The air filter might be clogged: remove and clean the air filter. * The carburetor might be dirty: take the unit to an authorized service center for cleaning....

Summary

Safety Definitions

Safety Alert Symbols Explained

Explains the meaning and use of safety alert symbols on the product and in the manual.

Safety Warning Symbols Guide

Details specific warning symbols found on the trimmer and their significance.

Control and Operating Symbols

Identifies and explains the function of various control and operating symbols used on the trimmer.

Important Safety Information

Owners Responsibilities

Outlines the owner's duties for safe operation, maintenance, and use of the trimmer.

Pre-Operation Safety Checks

Essential safety checks and precautions to take before starting and using the trimmer.

Safe Operation Guidelines

Guidelines for safe operating procedures, including bystander safety and personal condition.

General Safety Precautions

Covers precautions for slopes, wet conditions, visibility, engine exhaust, and debris.

Specifications

Features

Product Components Overview

Identifies and describes the main parts and features of the Powermate Field Trimmer.

Assembly

Handle and Control Cable Assembly

Step-by-step guide for assembling the trimmer's handle and control cable system.

Wheel Assembly

Instructions for correctly installing the wheels onto the trimmer unit.

Flexible Shield Assembly

Procedure for attaching the flexible shield to the trimmer unit.

Engine Preparation

Engine Oil Checks and Filling

Detailed steps for checking, adding, and verifying the correct engine oil level.

Fueling the Engine

Instructions for safely adding the correct type and amount of fuel to the engine.

Operation

Starting the Engine Procedures

Guides on preparing and starting the trimmer engine safely and effectively.

Stopping the Engine

Instructions on how to safely stop the trimmer engine.

Trimming Tips

Advice and techniques for effective and efficient grass trimming.

Trimming Tips and Slope Guidance

Further advice on trimming techniques and safe operation on slopes.

Slope Guide

Slope Operation Guidelines

Visual guide and instructions for safe trimmer operation on inclined surfaces.

Maintenance

Periodic Maintenance Schedule

A table outlining regular maintenance tasks and their recommended frequency.

Maintenance Notes

Important notes and tips regarding maintenance schedule and parts.

Oil and Air Filter Maintenance

Procedures for changing engine oil and cleaning or replacing the air filter.

Trimmer Line Replacement

Step-by-step guide for replacing worn or depleted trimmer line.

Spark Plug Check and Service

Instructions for checking, cleaning, and gapping the spark plug.

Drive Belt Replacement

Detailed steps for removing and replacing the trimmer's drive belt.

Storage Preparation

Guidelines for properly preparing the trimmer for long-term storage.

Technical Service

Troubleshooting

Troubleshooting Engine and Performance Problems

Identifies common problems and provides solutions for engine start, performance, and trimming issues.

Warranty

Limited Warranty Terms

Details the terms and duration of the limited warranty for the trimmer.

Emissions Control System Warranty

Information on the warranty coverage for the engine's emissions control system.

Owner Warranty Rights and Obligations

Explains the owner's responsibilities and rights concerning the warranty.

Emissions Warranty Details and Exclusions

Covers specifics of emissions warranty, obtaining service, exclusions, and liability limits.

Emissions Warranty Covered Systems

Lists the specific systems and parts covered under the emissions control system warranty.

Powermate PWFT14022 Specifications

General IconGeneral
BrandPowermate
ModelPWFT14022
CategoryTrimmer
LanguageEnglish

Related product manuals