Prince Castle McDonald's 625-MFY User Manual

Steamer 625-505
Rev G Printed in USA 1010 © 2003
Steamer
Steamer
625-MFY
625-MFY
Operation
Operation
Manual
Manual
355 East Kehoe Blvd. • Carol Stream, IL 60188
Phone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
LIMITED WARRANTY
This product (with the exception of the water tube, part no. 625-197S) is
warranted to be free from defects in material and/or workmanship for a period
of two (2) years from date of original installation, not to exceed 30 months from
date of shipment from our factory. P.C. Boards and Heater Assemblies are
warranted for three (3) years from date of installation, not to exceed 42 months
from date of shipment. Any component which proves to be faulty in material
and/or workmanship will be replaced or repaired (at the option of Prince
Castle, Inc.) without cost to the customer for parts or labor. This warranty
covers on location service (i.e. trip charges and/or mileage). Travel mileage
is limited to 100 miles (200 kilometers) round trip (one trip warranty) from an
authorized service agency or its sub-service agency.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this warranty.
• All labor shall be performed during regular work hours. Overtime premi-
um will be charged to the buyer.
• Damage caused by carelessness, neglect, and/or abuse (e.g., dropping,
tampering or altering parts, equipment damaged in shipment, by fire,
flood or an act of God) is not covered under this warranty.
TABLE OF CONTENTS
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Temperature Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
View Firmware Version . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Manual Reset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Programming Product Name & Water Cycle . . . . . . . . . . . . . . . . . . . . . . . .4
Error Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Cleaning - Daily . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Cleaning - Monthly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Exploded View and Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Control Panel
External Meter Plug Inlet
(for calibration)
On/Off Rocker Switch
(left-side of unit)
McDonalds
Logo Button
Product
Buttons
(1 thru 4)
Temperature &
UP Arrow Button
Prince Castle
Logo Button
Celsius/Fahrenheit &
DOWN Arrow Button
Start Button
LED Display
Spatula
Product Identification
SANITATION

Prince Castle McDonald's 625-MFY Specifications

General

Category	Kitchen Appliances
Model	625-MFY
Manufacturer	Prince Castle
Voltage	120V
Material	Stainless Steel
Usage	McDonald's

Summary

Product Identification

Limited Warranty

Safety Information

Important Design Notes

Prince Castle reserves the right to change specifications and product design without notice.

Installation Guide

Water Connection Requirements

If this is a new installation, accessory - 625-104 Regulatory Assembly Kit is required.

Steamer Operation

Temperature Calibration

Factory Presets Configuration

Loading factory presets restores the unit to factory settings and voids all user programmed information.

View Firmware Version

Press and hold the McDonald's LOGO button first, then press and hold the START button.

Manual Reset Procedure

A hi-limit thermostat will turn off electrical power to the platen and control circuits if the unit overheats.

Programming Product Names and Water Cycles

Programming Product Names

Steps to assign product names to buttons and enter custom product names.

Configuring Water Cycle Settings

Set the water valve ON and OFF times for programmed products.

Advanced Steamer Programming

Setting Water Cycle Number and Delay

Configure the number of water cycles and the alarm delay time.

Setting Platen Temperature

Adjust the platen temperature for programmed products.

Factory Pre-Set Temperatures

Error Messages and Troubleshooting

No Heat Error

Troubleshooting step for when the unit does not generate heat.

Daily Cleaning Procedures

Monthly Cleaning Procedures

Exploded View and Parts List

Available Steamer Accessories

List of additional accessories available for the steamer unit.

Troubleshooting Guide

Steamer Quick Start Guide

Operation Quick Reference

Concise guide on steaming buns and important operational tips.

Cleaning Quick Reference

Summary of daily and monthly cleaning procedures for the steamer.

Warranty Quick Reference

Overview of warranty coverage, exclusions, and limitations.

Water Tube Cleaning Procedure

Water Tube Replacement Procedure

Connecting Two Steamers

Rapid Steamer Series Manual

Precautionary Information

Important safety information regarding chemical products used in the manual.

Daily Cleaning Instructions

Detailed steps for daily cleaning of the steamer unit.

Monthly Cleaning Instructions