MAINTENANCE
In order to reduce the possibility of technical problems or injuries caused by improper operation of the
equipment and to ensure that all components operated safely, it is recommended to perform regular
maintenance on the mini tractor to keep it in good condition and expand its operating time.
In particular, fuel lines and rubber components should be replaced annually; electrical parts and wires
should be checked annually to ensure that all mechanical components are in the best condition.
Proper maintenance and lubrication will help keep the equipment in perfect working order. The equipment is
delivered without engine oil and transmission oil. The user must add the necessary oils before the first start.
The required quantities are mentioned in the user manual, in the table with Technical Data.
Make sure all screws and nuts are tight.
Schedule
Parts to be checked
and adjusted
Correct quantity Checking and adjusting Verification and replacement
period
Engine oil 1.4 L for diesel engine SAE30#, grade CC
(spring and summer),
SAE10W30, grade CC
(sezonul rece)
First change: after the first 20 hours
of operation
After first change, replace the oil
every 100 hours of operation.
1.2 L for gasoline engine SAE10W30, 10W40
Transmission (gear) oil
change
2.2 L for front gearbox
1.6 L for rear gearbox
0.2 L for transmission and
reductor gearbox
Gearbox oil 85W/90 First change: after first 40 hours of
operation.
After the first change, replace the oil
every 200 operating hours.
Cleaning the fuel filter Clean every 500 hours of operation,
replace the filter with a new one after
1000 hours of operation
Tire air pressure 1.2 kg/cm² Check before use
Cleaning the air filter 0.1 L the same type of
engine oil
Oil for gasoline engines Clean the air filter or change the oil
after 30-50 hours of operation under
normal conditions. Clean the air filter
or replace the oil every hour of
operation in severe conditions.
TROUBLESHOOTING
Troubleshooting for gasoline engine
Technical problems Components to be checked Solutions
Engine failure Fuel level Refuel
Spark plug Replace spark plug
Carburator atomization Clean or replace carburator
Check whether the switch ON/OFF is at OFF position Set switch to ON position
Battery voltage Check and charge battery
Fuse Replace fuse
Poor engine power Check wheather air filter is blocked Remove and clean filter element, then
add oil
Check oil level Add oil or change oil
Check choke Make sure choke is open
Check whether engine is compressed Replace piston and piston rings
Ver. 1/Rev. 2; Data: 18.09.2023
29
To Next Page
Loading...