Racing RAC4660PL-1 - User Manual

1
ORIGINAL INSTRUCTIONS
RAC4660PL-1
BUILDER SAS
32, rue Aristide Bergès - ZI 31270 Cugnaux – France
PETROL LAWNMOWER

Summary

General Safety Rules

Instructions

Read instructions carefully, be familiar with controls and proper use of the equipment.

Preparation Guidelines

Inspect area, handle fuel safely, check blades and ensure balance for safe operation.

Operation Guidelines

Mow in daylight, avoid greasy grass, use caution on slopes, walk not run.

Maintenance and Storage

General Maintenance Checks

Keep equipment tight, store safely, cool down before storage, keep clean.

Special Safety Instructions

User Training and Precautions

Seek training, use correct parts, switch off engine before maintenance, handle fuel carefully.

Fuel Handling

Safe Fueling Practices

Use caution with fuels, use approved containers, refuel outdoors, do not smoke.

During Maintenance and Storage

Service Precautions

Switch off tool, wait for parts to stop, allow to cool before servicing.

Residual Risks

Potential Hazards and Precautions

Be vigilant, health risks from vibration, injury from flying objects or attachments.

Intended Use

Product Application

Designed for natural grass mowing in gardens, not for public areas.

Care Instructions

First Aid Procedures

Keep kit available, provide accident details when calling for help.

Vibration Effects and Mitigation

Prolonged use can cause 'White finger disease', take breaks, keep hands warm.

Symbols

Understanding Safety Symbols

Explains warning signs and labels used in the manual for safety.

Description

Lawnmower Component Identification

Identifies and labels key parts of the lawnmower for user reference.

Assembly

Unpacking Procedure

Remove all packing materials, check for damages, dispose of materials properly.

Handle Setup and Height Adjustment

Open handle, screw parts together, attach recoil starter and cable.

Brake Cable Setup

Connect the brake cable to the hole of the brake lever.

Grass Bag Assembly

Slide grass bag frame into bag, attach clips, install grass bar.

Before Operation

Engine Oil Check and Fill

Check and fill engine oil to the correct level. Do not overfill.

Fueling Instructions

Refuel with correct octane unleaded petrol. Do not overfill.

Cutting Height Adjustment

Adjusting Cutting Height Settings

Check and adjust cutting height settings. There are 6 positions.

Operation

Starting the Engine

Push primer bulb in cold conditions before pulling starter handle.

Primer Use for Cool Engine

Table shows primer push times based on temperature for cold starts.

Control Operation for Mowing

Describes using controls for mowing, including operator lever and starter rope.

Self-Propelled Bar Operation

Push bar forward to move mower; release to stop forward movement.

Stopping the Engine

Release self-propelled bar and operator control lever to stop the engine.

Maintenance

Blade Inspection

Inspect blade for damage, cracks, rust. Check tightness of blade bolts.

Blade Removal and Installation

Wear gloves, use socket wrench to remove/install blade bolt and washers.

Grass Bag Cleaning and Replacement

Cleaning the Grass Bag

Wash bag with hose, allow to dry completely before use.

Replacing the Grass Bag

Unclip edges to remove frame, insert frame into bag, clip edges.

Engine Maintenance

Check Engine Oil Level

Check oil level when engine is off and horizontal. Do not overfill.

Change Engine Oil

Drain oil when warm, dispose of used oil responsibly. Refill with recommended oil.

Air Cleaner Service

Clean or replace filter element. Prevent dirt entry into the air duct.

Spark Plug Service

Disconnect cap, remove dirt, inspect, measure gap, install carefully.

Brake Lever Cable Adjustment

Adjust brake cable to tighten if the brake lever is loose.

Maintenance Schedule

Regular Service Intervals

Provides a schedule for regular service intervals for various components.

Troubleshooting

Engine Will Not Start

Checks for fuel, spark plug issues, and prime button use for starting problems.

Engine Lacks Power

Checks for air cleaner, fuel issues, and potential component malfunctions.

Storage

Proper Storage Procedures

Store without fuel for over a month, clean and store indoors, avoid flame/spark sources.

Environment Advice

Environmental Protection Guidelines

Use unleaded petrol, avoid spillage, dispose of oil responsibly, use original parts.

Technical Data

Product Specifications

Lists specifications like weight, dimensions, engine details, and performance metrics.

Declaration of Conformity EU

EU Compliance Statement

States compliance with EU directives and applicable standards.

Warranty

Ordering Spare Parts

Indicate part number/code, keep receipt, contact via phone or website.

Product Failure

Breakdown Resolution Steps

Steps for product failure, whether bought in-store or online.

Warranty Exclusions

Non-Covered Conditions

Lists conditions not covered by warranty, like normal wear, improper use, and lack of maintenance.

Racing RAC4660PL-1 Specifications

General

Brand	Racing
Model	RAC4660PL-1
Category	Lawn Mower
Language	English