riverhawk MP-0130 - Page 14

InstructionManualIM‐293

CUSTOMER'SINFORMATIONBOX
CONTENTSAREINDEPENDENTOFRIVERHAWKDOCUMENTCONTROL

215ClintonRoad
NewHartford,NY13413
Tel:+13157684855
Fax:+13157684941
Email:info@riverhawk.com


REV
373A4058
GEDRAWINGNUMBER

RevisionF
Page14of21

Theredoilreservoircapshouldberemovedandstoredinsidethepumpboxwiththeextraair
hosefittings.Placethegreyandblackstorageplugintotheoilreservoiropeningandtightento
securetheoilfromspillage

Placethehydraulicpumpkitintotheoriginalshippingcontainer.


8.0FrequentlyAskedQuestions

Thissectioncontainssomefrequentlyaskedquestionsandproblems.Ifthestepslistedheredo
notsolveyourproblem,contacttheRiverhawkCompanythruourwebsite,email,orphonecall.

Q:

A:

CanIrentahydraulictensionerkit?

Yes,Riverhawkhasrentaltensionerkitsavailableformostofourhydraulictensioners.
Q:

A:
Thehydraulicpumpappearstobeleakingordoesnotbuildpressure.

Checkthehoseconnectiontothehydraulicpump.Ifthehose’shighpressurefittingisnot
assembledcorrectlytothepump,itmaylooklikethepumpisleaking.Refertosections4.2.1
or4.2.2forthecorrectuseofthehighpressurefittings.

 Inspectandcleanthemaleconeattheendofthehose,theconemustbefreeofdamageand
debris.Also,inspectandcleanthefemaleconeatthebottomofthehydraulicport,thecone
mustalsobefreeofdamageanddebris.

Checkpumpbydeadheadingasdescribedinsection4.1.1orsection4.1.2.Iftheproblem
continues,contactRiverhawkforguidance.


Q:

A:
Thehydraulichoseappearstobeleakingwithglandnuttight.

Ifthehighpressurefittingisnotassembledcorrectly,itmaylooklikethehoseisleaking.Refer
tosections4.2.1or4.2.2forthecorrectuseofthehighpressurefittings.

Inspectandcleanthemaleconeattheendofthehose,theconemustbefreeofdamageand
debris.Also,inspectandcleanthefemaleconeatthebottomofthehydraulicport,thecone
mustalsobefreeofdamageanddebris.

