US
G B
G B
G B
G B
G B
When warranty repair is needed, the engine mus t be brought to an
authorized service dealer or warranty s tation’s place of business during
normal busines s hours . In all cases, a reas onable time, not to exceed
30 days, must be allowed for the warranty repair to be completed after
the engine is received by the authorized service dealer or warranty s tation.
G . MAINTE NANC E , R E P L A C E ME NT AND
R E P AIR OF E MIS S ION-R E L A T E D P A R TS
Only warranted engine replacement parts approved by F UJ I s hould
be us ed in the performance of any warranty maintenance or repairs
on emission-related parts . If other than authorized parts are us ed for
maintenance, replacement or repair of components affecting emission
control, you should ass ure yours elf that such parts are warranted by
their manufacturer to be equivalent to authorized parts in performance
and durability. F UJ I ,however, as s umes no liability under this warranty
with res pect to parts other than authorized parts. T he use of non-
authorized replacement parts does not invalidate the warranty on
other components unless the non-authorized parts caus e damage to
warranted parts.
H. P A R TS C OVE R E D UNDE R THE C AL IF OR NIA E MIS S IONS
WA R R ANTY
(1) F uel Metering S ystem
(i) C arburetor and internal parts
(ii) Air cleaner plate (including choke s ys tem)
(iii) Air cleaner cover
(iv) Air cleaner element
(2) Ignition S ys tem
(i) S park plug
(ii) F lywheel magneto
(iii) Ignition coil
(3) Mis cellaneous Items Us ed in Above S ystems
(i) Hos es and s ealing gaskets, bolts, connectors, and as semblies .
I. MA INT E NA NC E S TA T E ME NT S
It is your respons ibility to have all s cheduled inspection and maintenance services performed at the times recommended in the 2000 and later
Owner's Manual and to retain proof that ins pection and maintenance s ervices are performed at the times when recommended. F UJ I will not
deny a warranty claim s olely becaus e you have no record of maintenance; however, F UJ I may deny a warranty claim if your failure to perform
required maintenance resulted in the failure of warranted part. T he proof which you maintain should be given to each subs equent owner of the
engine. Y ou are respons ible for performing the s cheduled maintenance des cribed below bas ed on the procedures s pecified in the 2004 and
later Owner's Manual. T he scheduled maintenance below is bas ed on a normal engine operating schedule.
P R OC E DUR E INT E R VAL
1) C lean engine and check bolts and nuts. R etighten if neces sary. : E very 8 hours (daily)
2) C heck and refill engine oil (4 stroke) : E very 8 hours (refill daily up to upper limit)
3) C hange engine oil (4 stroke) : Initial 20 hours and every 100 hours afterward
4) C heck clogging of cooling air pass age and cylinder fins. : E very 8 hours (daily)
Note: More frequent maintenance may be neces s ary under dusty, dirty or s evere conditions.
(v) F uel F ilter
R emove and clean if neces s ary.
12) R eplace packings and gaskets with new ones.
11) Overhaul engine.
10) R eplace fule lines .
9) Adjust valve clearance, if applicable (4 s troke)
8) C heck fuel filter. If clogged, replace with new one.
7) C heck muffler exhaus t outlet (or port). C lean if neces sary.
6) C heck spark plug. C lean and adjust if neces s ary.
5) C lean air cleaner
: E very reass embling
: E very 200 hours
: E very 8 hours (daily)
: E very 8 hours (daily)
: E very 50 hours (monthly)
: E very 50 hours (monthly)
: E very 200 hours
: E very 200 hours
To Next Page
Loading...