19.
Steering box
or
steering
pump:
Check oi I I eve I
in
steering box
or
steering
pump
reservoirs; top-up
if
necessary.
20. Tappet adjustment: Check tappet clearances;
reset
if
necessary.
21. Tyres: Check
and
if
necessary adjust the tyre
pressures, including the spare. Al so check tyre
tread depth
and
tyre condition. Report any defects
to
the Owner.
22. Windscreen washer reservoir: Check the
fluid
level; top-up
if
necessary.
23. Bonnet and door locks: Lubricate bonnet
fasteners
and
locks, door locks, hinges
and
luggage
compartment locks.
24. Control linkages: Lubricate the gear range
selector controls, acceleration linkage
and
steering
column controls.
25. Test:
Road
test
the car for satisfactory
performance.
Every 16 000 kilometres (10 000
miles)
In
addition to the items I isted under the 8 000
ki I ometres
(5
000 miles) service schedule carry
out the
following.
In the case
of
Brakes, Carburetter, Fuel pumps,
Propeller shaft
and
Sparking plugs the aervicing
necessary
is
listed
in
this
schedule therefore, the
8 000 kilometres (5 000 miles) service schedule
should not be consulted
for
these items.
1. Brakes: Remove the brake drums and inspect
linings
for
wear; renew
linings
if necessary.
Adjust
if
necessary, the brakes and servo.
Lubricate brake pedal mechanism, pivot pins
and
bearings.
Check
fluid
level in brake reservoirs
and
top-up
if
necessary.
2. Brake master cylinder: Grease the master
cylinder balance lever bearing (where applicable).
3. Carburetters: Clean
filter
gauzes in
carburetter
float
chamber
lids.
Clean
air
valve dampers and top-up
with
engine
oil.
Check
slow
running speed and adjust
if
necessary.
4. Fuel pumps: Clean
filter
gauzes.
Test
operation
of each
pump
independently;
rectify
as necessary.
5. Main
line
fuel
filter:
Clean out main
line
filter
and
filter
bowl.
6.
Recirculatory heater
filter
(S1
cars only):
Clean recirculatory heater
filter.
7. Refrigeration system
(If
fitted):
Grease the
coolant bearing.
8. Shock dampers: Check front and rear shock
dampers for
oil
leakage; top-up
if
necessary.
9. Sparking plugs:
Fit
new sparking plugs
ensuring the gaps are set
correctly.
10.
Starter motor: Check starter motor reduction
gear
oil
level;
top-up
if
necessary.
11. Dynamo: Lubricate rear dynamo bearing
(if
applicable).
12. Propeller shaft: Lubricate the propeller
shaft
universal
joints
and
sliding
joint.
On
cars
fitted
with
an
automatic gearbox check
that the ball
and
trunnion rubber cover
is
secure
and
in good condition.
82
Also check that the four
bolts
securing the
propeller shaft to the gearbox are
tight.
13. Track rods
(S1
cars only): Lubricate the track
rod
grease points.
Every 32 000 kilometres (20 000 miles}
In addition to the 8 000 kilometres
(5
000 miles)
and
16
000 kilometres (10 000 miles) service
schedules carry out the
following.
In the case
of
the Chassis lubrication system,
Gearbox, Propeller shaft
and
Rear axle the
servicing necessary
is
listed
in
this
schedule
therefore, the previous schedules should not
be
consulted
for
these items.
1.
Chassis lubrication system: Check for
excessive leakage;
rectify
as necessary.
Renew the
felt
strainer pad located
at
the
base
of
the chassis oi I pump.
Operate the foot
pump
three
or
four times.
This
will
ensure adequate lubrication
of
remote
parts
of
the system.
Check the oi I I eve I
in
the
chassis
oi
I tank;
top-up if necessary.
2. Fuel tank: Release the drain plug
and
allow
any accumulated water to drai,:i away.
3. Gearbox: Change gearbox
oi
I.
Clean the breather in the top
of
the
dipstick
(applicable only to cars
fitted
with
an
automatic
gearbox).
4.
Pro
pe
11
er
shaft: Lu br i cat e p rope
II
er
sh
aft
universal
joints
and
sliding
joint.
On
cars fitted·
with
an
automatic gearbox check
that the bal I
and
trunnion
joint
rubber cover
is
secure and
in
good condition.
If
the
joint
shows
signs of leakage, dismantle the
joint,
inspect,
rectify
as necessary
and
then refi
11
with
grease.
Also check that the four
bolts
securing the
propeller shaft to the gearbox are
tight.
5.
Rear
axle:
Change rear
axle
oil.
6.
Steering
pump
(If
fitted):
Renew
filter
element.
7. Vokes
air
filter
element (Continental models
only): Renew
air
filter
element.
Every 96 500 kilometres (60 000 miles)
In addition to the 8 000 kilometres (5 000
miles),
16
000 kilometres (10 000 miles) and the 32 000
kilometres (20 000 miles) service schedules carry
out the
following.
1. Propeller shaft: Examine the propeller shaft
centre bearings
and
re-pack
with
grease.
Recommended Seasonal Schedules
Every
12
months
1. Engine cooling system: Drain the coolant from
the radiator and engine crankcase. Thoroughly
flush out the coolant passages
with
a continuous
flow
of
water.
This
should be carried out
just
prior
to the Autumn.
Fi
11
the system with the correct
anti-freeze/
water mixture
or
inhibited solution.
Every 2 years
In addition to the
12
monthly schedule carry out
the
following.
To Next Page
Loading...
Need help?
General
