'O
C
~
C)
C
w
C
ct
~
0
~
<1>
u
>
£
.
!!!.
0
cc
©
.8
~
u
.,
0
0
<F)
I-
Torque converter transmission
Change the transmission
fluid.
Preventive Maintenance
Control linkages
Apply a few drops
of
engine oi I to the accelerator
linkage
and
to the gear range
selector
controls
adjacent to the transmission
casing.
Electrical system
Check al I
interior
lamps,
exterior
lamps,
instruments, warning lamps and
devices
for correct
operation;
rectify
if necessary.
Parking brake I inkage
Lubricate
the
pivot
pins
and
pulleys
in
the parking
brake system
with
approved grease.
Spare wheel carrier
Lubricate
the spare wheel
carrier
lowering
bolt
and
mechanism.
Tyres
Check the tread depth
of
al I tyres, inspect al I the
tyres for signs of damage. Check the tyre pressures
when they are
cold
and
adjust
if
necessary.
Note
I
nc1
ude the spare tyre.
Test
Road
test
the car for
satisfactory
performance.
30 000 kilometres (18 000 miles) or 18 months
service whichever
is
the earlier
Essential Maintenance
Engine
Change the engine
oil.
Fit
a new
oil
filter.
Exhaust system
Check grass-ti
re
heatshields for damage.
Rectify
or
renew
shields
to ensure that a minimum clearance
of
5
mm.
(0.20 in.)
is
maintained between the
heatsh
ields
and exhaust
pipes.
Battery
Check the level
of
the
electrolyte
and
if
necessary,
top-up
with
distilled
water.
Belt tension
Check the tension of
all
driving
belts
and reset if
necessary.
Brakes
Inspect the footbrake and parking brake
pad
I inings;
fit
new
linings
if
necessary.
When
changing the
footbrake pads examine the
condition
of the dust
excluders
on
the calipers; renew
if
necessary.
Manual
1y
adjust the parking brake pads.
Inspect
all
brake
pipes
and connections; the
Franchise holder should report any defects to the
Owner.
Fluid levels
Check
all
fluid
levels
and correct if necessary.
Preventive Maintenance
Carburetters
Top-up the
oil
level
in the
air
valve
dampers.
Control
Ii
nkages
Apply a few drops of engine oi I to the accelerator
Ii nkage
c1nd
to the gear range
selector
controls
adjacent to the transmission
casing.
Electrical system
Check
all
interior
lamps,
exterior
I amps,
instruments. warning I
amps
and devices for
correct
operation;
rectify
if
necessary.
Parking brake I inkage
Lubricate
the
pivot
pins
and
pulleys
in
the parking
brake system with approved grease.
Tyres
Check the tread depth
of
all
tyres, inspect
all
tyres
for
signs
of
damage. Check the tyre pressures
when they are
cold
and
adjust
if
necessary.
Note
Include the spare tyre.
Test
Road test the
car
for
satisfactory
performance.
40 000 kilometres (24 000
miles)
or
2 years
service whichever
is
the
earlier
Essential Maintenance
Air
injection
pump
Check the
belt
tension and reset
if
necessary.
Air injection system
Check the
air
injection
system for leaks and correct
operation; renew any
defective
items.
Air
silencer
Fit
a new
air
filter
element.
Automatic choke
Check the
air
flow
through the choke stove
pipe
and
check
for
correct operation;
rectify
if
necessary.
Carburetters
Clean the
air
valves.
Remove the fi
lier
cover from
each carburetter fuel
filter
housing and
fit
a new
paper
filter
element.
Top~p
the
oil
level
in
the
air
valve
dampers. Check the
float
chamber depression
and
rectify
if
necessary. Check the
idle
speed and
rectify
if
necessary. Check the choke
fast-idle
speed and
rectify
if
necessary.
Carburetter mixture weakening device
Fit
a new
air
filter
element.
Crankcase emission control system
Remove and clean the gauze flame traps
in
the
crankcase breather tube. Clean the adapter
in
the
choke
butterfly
housing.
E20 - 5
To Next Page
Loading...
