"O
C
«s
-a,
C:
LLI
C:
©
Preventive Maintenance
Control linkages
Apply a few drops of engine
oil
to the accelerator
I
ink age
and
to the gear ran9e
selector
controls
adjacent to the transmission casing.
Electrical system
Check
all
interior
lamps,
exterior
lamps,
instruments, warning lamps
and
devices
for
correct
operation;
rectify
if necessary.
Parking brake linkage
Lubricate
the
pivot
pins and
pulleys
in the parking
brake system with approved grease.
Spare wheel carrier
Lubricc1te the spare wheel carrier lowering
bolt
and
mechanism.
Tyres
Check
the
tread depth of al I tyres, inspect al 1 the
tyres for signs of damage. Check the tyre pressures,
when they are
cold
and adjust
if
necessary.
Note
Include the spare tyre.
Test
Road
test
the
car
tor
satisfactory
performance.
30 000 kilometres (18 000 miles)
or
18 months
service whichever
is
the earlier
Essential Maintenance
Engine
Change the engine oi I.
Fit
a new oi I fi 1 ter.
Battery
Check the level
of
the
electrolyte
and
if
necessary,
top-up
with
distilled
water.
Belt tension
Check the tension of
all
driving
belts
and reset
if
necessary.
Brakes
Inspect the footbrake
and
parking brake pad
linings;
fit
new
linings
if
necessary.
When
changing the
foot brake pads examine the condition of the
dust
excluders
on
the calipers; renew
if
necessary.
Manual I
y adjust the parking brake pads.
Inspect al I brake pipes and conneclions; the
Franchise
Holder
should reporl any
defects
to the
Owner.
Fluid levels
Check
all
fluid
levels
and
correct as necessary.
Preventive
Maintenance
Carburetters
Top-up the
oil
level in the
air
vc1lve
dampers.
Control linkages
Apply a few drops
of
engine oi I to the accelerator
linkage
and
to the gear range
selector
controls
adjacent to the transmission
casing.
Electrical system
Check
all
interior
lamps,
exterior
lamps,
instruments, warning lamps
and
devices
for
correct
operation;
rectify
if
necessary.
Parking brake linkage
Lubricc1te the
pivot
pins
and
pulleys
in
the parking
brake system
with
approved grease.
Tyres
Check the tread depth of
all
tyres, inspect
all
tyres
for
signs
of
damage. Check the
tyre
pressures
when they are cold and
adjust
if
necessary.
Note
Include the
spc1re
tyre.
Test
Road
test
the car for
satisfactory
performance.
40 000 kilometres (24 000 miles) or 2 years
service whichever
is
the
earlier
Essential Maintenance
Air
injection
pump
Check the belt tension
and
reset
if
necessary.
Air
injection system
Check the
air
injection
system for leaks
and
correct
operation; renew any
defective
items.
Air
silencer
Fit
a new
air
fi
Iler
element.
Automatic choke
Check the
air
flow
through the choke stove
pipe
and
check for correct operation;
rectify
if
necessary.
Carburetters
Clean the
air
valves.
Remove the
filter
cover from
each carburetter fuel fi
lier
housing and
fit
a new
paper
filter
element. Top-up the
oil
level
in the
air
valve dampers. Check the
float
chamber depression
and
rectify
if
necessary. Check the
idle
speed and
rectify
if
necessary. Check the choke
fast-idle
speed and
rectify
if
necessary.
Carburetter mixture weakening device
Fil
a new
air
filter
element.
Crankcase emission control system
Remove and clean the gauze flame traps in the
crankcase breather tube. Clean the adapter
in
the
choke
butterfly
housing.
E22 - 5
To Next Page
Loading...
