Every
16
000 kilometres
(10
000 miles)
In addition to the items
listed
under the 8 000
kilometres (5 000 miles) service schedule carry
out the fo
11
owing except for Sparking plugs where
this
schedule should
be
consulted.
1.
By-pass
oil
filter:
Fit
a new by•pass
oil
filter
element.
2.
Propeller
shaft: Lubricate propeller
shaft
universal
joints
and
sliding
joint.
3. Shock dampers: Check
and
if necessary top·up
the front
and
rear shock dampers
with
oil.
4. Sparking plugs:
Fit
new sparking plugs
ensuring that the gaps are set
correctly.
5. Starter motor: Check
starter
motor reduction
gear
oil
level;
top·up
if
necessary.
6. Tappet adjustment: Check tappet clearances;
reset
if
necessary.
Every 32 000 kilometres
(20
000 mil.es)
In addition
to
the 8 000 kilometres (5 000 miles)
and
16
000 kilometres (10 000 miles) service schedules
carry out the fol lowing.
In the case
of
Chassis
lubrication
system,
Gearbox and Rear
axle
the
servicing
necessary
is
Ii
sted
in
this
schedule therefore, ttie previous
schedules should
not
be consulted for these items.
1.
Chassis
I ubrication system: Check
for
excessive
leakage;
rectify
as necessary.
Renew
the
felt
strainer pad located at the base
of
the
chassis
oil
pump.
Operate the foot
pump
three
or
four
times.
This
wi
11
ensure adequate I ubrication of remote parts
of
the system.
Check the
oil
level in the
chassis
oil
tank;
top-up
if
necessary.
2. Dynamo and starter motor: Inspect brushes
for
signs
of
wear; renew if necessary.
3. Fuel
filters:
Clean out the f,ilter gauzes and
filter
bowl.
Also,
remove
and
clean the gauze
filter
in the carburetter
float
chamber.
4. Fuel tank: Release the drain
plug
and
al
low
any
accumulated water to drain away.
5. Gearbox: Change gearbox oi I.
6. Rear
axle:
Change rear
axle
oil.
Recommended Seasonal Schedules
Every
12
months
1. Engine
cooling
system: Drain and
flush
the
cooling
system.
Fill
the system
with
the correct
anti-freeze/water
mixture
or
inhibited
solution.
Every 2 years
In addition to the
12
monthly schedule carry out
the fol
lowing.
1. Coolant hoses: Renew
all
coolant
and
heater
hoses.
D1
- 2
To Next Page
Loading...
