filter
element in the scuttle intake
grille
is
free
from
obstruction;
fit
a new element
if
necessary.
On
Long wheelbase cars
fitted
with a centre division,
ensure that the
foam
filter
element
fitted
below the
rear refrigeration system
air
intake
grille
is
free from
obstruction.
Fit
a new
filter
element
if
necessary.
Check the refrigeration system for correct
operation,
rectify
as
necessary. Any work
on
the
refrigeration system must only
be
carried out
by
an
experienced refrigeration engineer.
2. Body drain holes: Ensure that the body drain
holes
are
not obstructed.
3. Engine cooling system: Drain
off
the old
coolant
and
fil I the system with fresh anti-freeze/
water mixture. Just prior to the Autumn, clean any
debris from the surfaces
of
the refrigeration condenser
and
radiator matrices
by
reverse flushing with a hose.
Every 2 years
1. Engine cooling
system.:
Carry out the
12
months service procedure and also· thoroughly
reverse flush the cooling system. Examine coolant
hoses
and
fit
new hoses as necessary.
Service Recommendations
It
is
emphasised that these service recommendations
are not normal servicing arrangements
and
should
only
be
carried out at the request
of
the Owner.
Every
48
000 miles
1. Brake
and
hydraulic systems:
Fit
new front
and
rear accumulator to frame hoses. Examine the
condition
of
the sub-frame to brake
caliper
hoses;
fit
new hoses where necessary. Drain
off
the
hydraulic fluid; clean out the hydraulic
fluid
reservoirs and clean the sight glasses.
Fill
the
systems with fresh Castrol
RR
363 Brake
Fluid
and bleed the systems.
Every 96 000 miles
1. Brake
and
hydraulic systems:
Fit
all
new
flexible
hoses to the brake
·and
hydrau I
ic
systems.
Fit new seals to the
disc
brake calipers, the
deceleration conscious pressure
limiting
valve,
and
the master cylinder. Drain
off
the hydraulic
fluid;
clean out the hydraulic
fluid
reservoirs and clean
the sight glasses.
1Fi
11
the systems
with
fresh
Castro!
RR
363 Brake
Fluid
and
bleed the systems.
2.
Fuel system:
Fit
a new convoluted hose
between the
ti
Iler
head
and
the fuel tank. Examine
all
flexible
fuel pipes; renew
any
that
show signs
of
deterioration.
E2
- 4
To Next Page
Loading...
