Preventive
Maintenance
Initial
Service
This
service
should be
carried
out by the Dealer
after
the
first
5 000
km
(3
000
miles)
or 3 months
whichever
is
the
earlier.
1. Steering pump: Check the oi I level in the
reservoir,
top-up
if
necessary.
2.
Test:
Road
test
the car
for
satisfactory
performance.
Every
10
000 kilometres (6 000 miles) or
6 months whichever
is
the earlier
1.
Carburetters: Check
the
air
valve
damper oi I
levels;
top-up
if
necessary.
2. Control
linkages:
Lubricate
the
accelerator
linkage
and the gear range
selector
controls
(adjacent to the
transmission
casing),
with
engine
oil.
3.
Electrical
system: Check
all
interior
lamps,
exterior
lamps,
instruments,
warning lamps and
devices
for
correct
operation:
rectify
as
necessary.
4.
Handbrake or parking brake I inkage:
Lubricate
the
pivot
pins
and
pulleys
in
the
handbrake or
parking
brake system with the approved
grease.
5.
Tyres:
Check
the
tread depth
of
al I
tyres,
including
the spare.
Inspect
for
signs
of
damage
and check
all
five
tyre
pressures when
cold.
Adjust
if necessary.
6.
Test:
Road
test
the
car
for
satisfactory
per1ormance.
Every 20 000 kilometres (12 000 miles) or
12
months whichever
is
the
earlier
1. Control I
ink
ages:
Lubricate
the
accelerator
linkage
and
the gear range
selector
controls
(adjacent to the
transmission
casing),
with
engine
oil.
2.
Handbrake
or
Parking
brake linkage:
Lubricate
the
pivot
pins
and
pulleys
in
the
handbrake
or
parking brake system
with
approved
grease.
3.
Spare wheel
carrier:
Lubricate
the
spare
wheel
carrier
I owerin g
bolt
and mechanism.
4.
Electrical
system:
Check
all
exterior
lamps,
interior
lamps, instruments, warning lamps and
devices
for
correct
operation;
rectify
as
necessary.
5.
Tyres:
Check the tread depth of al I
tyres,
including
the spare.
Inspect
for
signs
of
damage and
check
al I
five
tyre
pressures when
cold.
Adjust
if
necessary.
6.
Test:
Road
test
the
car
for
satisfactory
perf
or
man
c e.
Every 30 000 kilometres
(18
000
miles)
or
18 months whichever
is
the
earlier
1. Carburetters: Check
the
oil
level
in
the
air
valve
dampers; top-up
if
necessary.
2.
Control
linkages:
Apply
a few drops
of
engine
oi I
to
the
accelerator
Ii
n kage and
gec>r
range
selector
controls
adjacent
to
the
transmission
casing.
E9 - 4
3.
Electrical
system: Check al I
interior
lamps,
exterior
lamps, instruments, warning lamps and
devices
for
correct
operation.
Rectify
as necessary.
4.
Handbrake and
Parking
brake 1
in
kage:
Lubricate
the
pivot
pins
and
pulleys
with
approved
grease.
5.
Tyres:
Check
the
tread depth of al I
tyres,
including
the spare.
Inspect
for
signs
of
damage
and check al I
five
tyre
pressures when
cold.
Adjust
if
necessary.
6.
Test:
Road
test
the
car
for
satisfactory
performance.
Every 40 000 kilometres (24 000 miles)
or
2 years whichever
is
the
earlier
1. Control linkages~
Apply
a
few
drops
of
engine
oi
I to
the
acc::ilerator
linkage
and gear range
selector
controls
adjacent
to
the
transmission
casing.
2.
Electrical
system: Check
all
exterior
lamps,
interior
lamps, instruments, warning lamps and
devices,
for
correct
operation;
rectify
as necessary.
3.
Fuel
filter:
Clean out
the
filter
bowl and
fit
a new
filter
element.
4.
Fuel
tank. Slacken
the
drain
plug
one or two
turns and
allow
any accumulated water
to
drain
away.
Tighten
the drain
plug.
5.
Height
control
mechanism.
Disconnect
the
control
valve
I inkage bal I
joints.
Clean,
grease and
refit.
6.
Handbrake
or
Parking
brake linkage.:
Lubricate
the
pivot
pins
and
pulleys
in
the
handbrake
or
parking brake system
with
approved
grease.
7.
Spare wheel
carrier:
Lubricate
the spare
wheel
carrier
lowering
bolt
and mechanism.
6.
Tyres
Check
the
tread depth
of
al I
tyres,
including
the spare. Inspect
for
signs
of damage
and check
all
five
tyre
pressures when
cold.
Adjust
if
necessary.
9.
Test:
Road
test
the
car
for
satisfactory
performance.
Servicing
:tfter
40 000 i<ilometres (24 000 mi
le$)
or 2 years whichever
is
the
earlier
After
40
000
kilometres
(24
000
milt:s)
or
2 years,
servicing
is
still
due at
the
following
intervals.
50 000
kilometres
(30
000
miles)
or
211?
years
whichever
is
the earlier
Carry out
the
10
000
km
(6
000
miles)
service.
50
000 kilometres (36 000 miles) or 3 years
whichever
is
the earlier
Carry out the
20
000
km { 12 000
miles)
service.
70
000 kilometres (42 000 miles)
or
3
1
/i
years
whichever
is
the
earlier
Carry
out
the 10 000 km (6 000 mi I es)
service.
80
000
kilometres (48 000 miles) or 4 years
whichever
is
the earlier
Carry out the
40
000
km
(24
000
miles)
service.
/
To Next Page
Loading...
