't,
C
ti!
CJ
C
w
©
Preventive Maintenance
Control
Ii
nkages
Apply
a few drops of engine
oil
to the accelerator
I inkage and to the gear range selector
controls
adjacent to the transmission casing.
Electrical system
Check al I
interior
lamps,
exterior
lamps,
instruments, warning lamps and devices
for
correct
operation;
rectify
if
necessary.
Parking brake linkage
Lubricate
the
pivot
pins
and
pulleys
in the parking
brake system with approved grease.
Spare
wheel carrier
Lubricate
the spare wheel
carrier
lowering
bolt
and
mechanism.
Tyres
Check the tread depth of
all
tyres, inspect
all
the
tyres
for
signs
of
damage. Check the tyre pressures,
when they are
cold
and
adjust
if
necessary.
Note
Include the spare tyre.
Test
Road
test
the car for
satisfactory
performance.
30 000 kilometres (18 000
miles)
or
18 months
service whichever
is
the earlier
Essential Maintenance
Engine
Change the engine
oil.
Fit
a new
oil
filter.
Battery
Check the level
of
the
electrolyte
and
if
necessary,
top-up with
distilled
water.
Belt tension
Check the tension
of
all
driving
belts
and reset
if
necessary.
Brakes
Inspect the footbrake and parking brake pad I
ini
ngs;
fit
new
linings
if
necessary.
When
changing the
footbrake pads examine the condition
of
the
dust
excl
uders
on
the
calipers;
renew
if
necessary.
Manually
adjust
the parking brake pads.
Inspect
all
brake pipes and connections; the
Franchise
holder should report any defects to
the
Owner.
Fluid levels
Check al I
fluid
levels
and correct as necessary.
Preventive Maintenance
Carburetters
Top-up the
oil
level in the
air
valve dampers.
Control linkages
Apply a few drops
of
engine
oil
to the accelerator
Ii nkage and to the gear range
selector
controls
adjacent to the transmission
casing.
E lectrica I system
Check al I
interior
lamps,
exterior
lamps,
instruments, warning lamps and
devices
for correct
operation;
rectify
if
necessary.
Parking brake I inkage
Lubricate
the
pivot
pins
and
pulleys
in the parking
brake system
with
approved grease.
Tyres
Check the tread depth
of
all
tyres, inspect al I tyres
for
signs
of
damage. Check the
tyre
pressures
when they are
cold
and
adjust
if necessary.
Note
Include the spare tyre.
Test
Road
test
the
car
for
satisfactory
performance.
40 000 kilometres (24 000 miles)
or
2
years
service whichever
is
the
earlier
Essential Maintenance
Air
injection
pump
Check the
belt
tension and reset if necessary.
Air
injection system
Check the
air
injection
system for leaks and correct
operation; renew any
defective
items.
Air
silencer
Fit
a new
air
fi
Iler
element.
Automatic choke
Check the
air
flow
th rough the choke stove
pipe
and
check for correct operation;
rectify
if
necessary.
Carburetters
Clean the
air
valves.
Remove the
filter
cover from
each carburetter fuel
fi
Iler
housing and
fit
a new
paper
filter
element. Top-up the
oil
level
in
the
air
valve dampers. Check the
float
chamber depression
and
rectify
if
necessary. Check the
idle
speed and
rectify
if
necessary. Check the choke
fast-idle
speed and
rectify
if necessary.
Carburetter mixture weakening device
Fit
a new
air
filter
element.
Crankcase emission control system
Remove and clean the gauze flame traps
in
the
crankcase breather tube. Clean the adapter
in
the
choke
butterfly
housing.
E19 • 5
To Next Page
Loading...
