0
co
Q)
<-
©
Tyres
Check the tread depth of
all
tyres, inspect
all
tyres
for signs of damage. Check the tyre pressures
when they are cold and
adjJst
if
necessary.
Note
Include the spare tyre.
Test
Road
test
the car for
satisfactory
performance.
50
O~O
kilo.metres
(30
000 miles) or
21/i
years
service whichever
1s
the
earlier
Essential Maintenance
Engine
Change the engine
oil.
Fit
a new
oil
filter.
Battery
Check the level
of
the
electrolyte
and
if
necessary,
top-up
with
distilled
water.
Belt
tension
Check the tension
of
all
driving
belts,
reset
if
necessary.
Brakes
Inspect the footbrake and parking brake pad 1 i nings,
fit
new
linings
if necessary.
When
cha.iging the
footbrake pads examine the condition
of
the dust
excluders
on
the calipers; renew
if
necessary.
Manually
adjust
the parking brake pads.
Inspect al I brake pipes and connections; the
Franchise
Holder
should report any defects to the
Owner.
Fluid
levels
Check
all
fluid
levels
and correct as necessary.
Preventive Maintenance
Carburetters
Top-up the
oil
level in the
air
valve dampers.
Control
Ii
nkages
Apply a few drops of engine
oil
to the accelerator
linkage and to the gear range
selector
controls
adjacent
to
the transmission casing.
Electrical system
Check al I
interior
lamps,
exterior
I amps, instruments,
warning lamps and devices
for
correct operation;
rectify
if
necessary.
Parking brake linkage
Lubricc1te the
pivot
pins
and
pulleys
in the parking
brake system
with
approved grease.
Tyres
Check the tread depth of
all
tyres, inspect
al
I tyres
for
signs of damage. Check the tyre pressures when
they are cold and
adjust
if necessary.
Note
Include the spare tyre.
Test
Road
test
the car
for
satisfactory
performance.
60 000 kilometres (36
000
miles) or 3 years
service whichever
is
the
earlier
Essen ti a I Maintenance
Air
injection
pump
Check the
belt
tension and reset
if
necessc1ry.
Air
silencer
Fit
a new
air
filter
element.
Carburetters
Top-up the oi I level
in
the
air
valve dampers. Check
the
float
chamber depression
and
rectify
if
necessary. Check the
idle
speed and
rectify
if
necessary. Check the choke
fast-idle
speed
and
rectify
if
necessary.
Crankcase emission control system
Clean the gauze flame traps
in
the crankcase
breather tube. Clean the adapter in the choke
butterfly
housing.
Engine
Change the engine
oil.
Fit
a new oi I
filter.
Exhaust manifolds
Check torque tightness of the exhaust manifold
bolts.
Fuel evaporative emission control system
Check the condition
of
the pipes and connections;
rectify
if
necessary.
Ignition system
Fit
new sparking
plugs
ensuring that the gaps are
correctly set.
Lubricate
the
distributor
spindle
(shaft bearings)
c1nd
automatic advance mechanism
with
engine
oil.
Check the
ignition
timing and
reset
if
necessary. Check the engine
idle
speed and
rectify
if
necessary.
Battery
Check the level
of
the
electrolyte
and
if
necessary,
top-up with
distilled
water.
Seit
tension
Check the tension
of
all
driving
belts
and reset
if
necessary.
Brakes
l~spect ~h:
foot_brake
and parking brake pad
linings:
fit
new
linings
1f
necessary.
When
changing the
footbrake pads examine the condition
of
the dust
excluders
on
the
calipers;
renew
if
necessary.
Manually
adjust
the parking brake pads.
Inspect al I brake pipes
and
connections; the
Franchise
Holder
should report any defects to the
Owner.
Fluid
levels
Check
all
fluid
levels
and
correct as necessary.
Front suspension
Inspect the front suspension ball
joint
rubber
covers, if the covers are found to
be
damaged,
fit
new
joints
and covers.
E22 - 7
To Next Page
Loading...
