.,,
c::
CII
0)
C
w
. :
i
C
'&
a.
<(
Servicing
after
SO
000
miles
or
4 years
whichever
is
the
earlier
After
50
000
miles
or
4 years, servicing
is
still
due
at
either
6
Ot>O
mi
I es or 6 500 mi I
es
intervals.
Therefore the respective 6 000
miles,
12
000 miles,
25
000
miles
or
50
000
miles
Essential
Maintenance
service schedule should
be
carried out
as
described previously.
Preventive Maintenance
lniti
al Service - 3 000
mi
,es
or
3 months
whichever
is
the earlier
1.
Belts
and
belt
tension: Check the condition
and
tension
of
the
belts
driving
the cool ant pump,
steering
pump
and
refrigeration compressor
and
the
alternator; adjust
or
replace as necessary.
2. Steering pump: Check the
fluid
level
of the
steering
pump
reservoir; top-up
if
necessary.
3.
Test:
Road
test
the car for
satisfactory
performance.
6 000 miles
or
6 months whichever
is
the
earlier
1.
Belts
and
belt
tension: Check the
condition
and
tension
of
the
belts
driving
the coolant pump,
steering
pump
and
refrigeration compressor
and
the
alternator;
adjust
or replace
as
necessary.
2. Carburetters: Check the
oil
level
in
the
air
valve
dampers: top-up
if
necessary.
3. Control I inkages:
Lubricate
accelerator
linkage
and
the gear range
selector
controls
(adjacent
to
the transmission casing)
with
engine
oil.
4.
Electrical
system: Check al I
exterior
lamps,
interior
lamps, warning lamps and
devices,
instruments and
air
conditioning
controls
for
correct
operation,
rectify
as
necessary.
5.
Parking brake linkage:
Lubricate
the
pivot
pins
and
pulleys
with
the approved grease.
6.
Check the fol I owing I eve
Is
and
pressures:
Check the
fluid
level in the steering pump
reservoir
and top-up
if
necessary.
Check the level
and
specific
gravity
of
the
engine coolant; correct as necessary.
Check the
fluid
level
in
the windscreen
washer reservoir and top-up
if necessary.
Run
the engine for four minutes then check
the
fluid
levels
of
the
hydraulic
system reservoirs;
top-up
if
necessary
with
recommended
fluid.
Check and
if
necessary adjust the
tyre
pressures. Inspect the tread depth
of
al
I
tyres;
also
inspect the tyres
for
damage. Report any
defects
to
the Owner.
7.
Test:
Road
test
the car for
satisfactory
performance.
12 500 miles
or
12 months whichever
is
the
earlier
1.
Belts
and
belt
tension: Check
the
condition
and tension
of
the
belts
driving
the
coolant
pump,
steering
pump
and refrigeration compressor and the
alternator;
adjust
or replace as necessary.
2. Control I inkages:
Lubricate
accelerator
linkage
and
the gear range
selector
controls
(adjacent to the transmission casing)
with
engine
oil.
3.
Electrical
system: Check al I
exterior
I amps,
interior
lamps, warning lamps
and
devices,
instruments and
air
conditioning
controls
for correct
operation;
rectify
as necessary.
4. Parking brake linkage:
Lubricate
the
pivot
pins
and
pulleys
with
the approved grease •
5.
Spare
wheel carrier:
Lubricate
the spare
wheel carrier lowering
bolt
and
mechanism.
6. Check the
following
levels
and pressures:
Check the
fluid
level in the steering
pump
reservoir
and
top-up
if
necessary.
Check the
fluid
level in the steering
idler
box damper; top-up
if
necessary.
Check the level and
specific
gravity
of the
engine coolant; correct as necessary.
Check the
fluid
level in the windscreen
washer reservoir and top-up
if necessary.
Run
the engine for four minutes then check
the
f I
uid
levels
of the hydrau
Ii
c systems reservoirs,
top-up
if
necessary
with
recommended
fluid.
Check
and
if
necessary adjust the tyre
pressures. Inspect the tread depth
of
all
tyres;
also
inspect the tyres for damage. Report any
defects
to
the Owner.
7.
Test:
Road
test
the car
for
satisfactory
performance.
25 000 miles
or
2 years whichever
is
the
earlier
In addition
to
the 12 500
miles
Preventive
Maintenance schedule carry out the
fol
lowing.
1. Fuel
filter:
Clean out the
filter
bowl
and
fit
a new
filter
element.
2. Fuel pump: Remove pumps
and
test
fuel
pump
efficiency;
fit
new pumps
if
necessary.
3. Fuel tank: Release the fuel tank drain plug,
allow
any accumulated
water
to drain away and
then tighten the plug.
4. Height control mechanism: Disconnect,
clean
and
lubricate
the
height
control
valve
bal I
joints;
connect
ball
joints.
5. Rear wheel
drive
shaft:
Lubricate
the outer
universal
joints
with
approved grease.
Servicing after
25
000
miles
or
2 years
whichever
is
the earlier
After
25
000
miles
or
2 years,
servicing
is
s.ti
II due
at
either
6 000
miles
or
6
500
miles
intervals.
Therefore, the
respective
6 000
miles,
12 500
miles
or
25
000
miles
Preventive
Maintenance
service
schedule should be carried out
as
described
previously.
Recommended
Seasonal Schedules
Every
12 months
1.
Air
conditioning
system: Check that the
foam
filter
element in the
scuttle
intake gri I le
is
free from obstruction;
fit
a new element
if
necessary.
On
Long wheelbase
cars
fitted
with
a centre
division,
ensure that the foam
filter
element
fitted
below the rear
refrigeration
system
air
intake
grille
is
free from
obstruction.
Fit
a new
filter
element
if
necessary.
To Next Page
Loading...
