5.
Tyres:
Check the tread depth
of
all
tyres,
including
the spare.
Inspect
for signs
of
damage and
check
al
I
five
tyre pressures when
cold.
Adjust
if
necessary.
6.
Test:
Road test the car for
satisfactory
performance.
Every
30
000
kilometres (18 000
miles)
or
18
months whichever
is
the
earlier
1.
Carburetters: Check the
oil
level
i;i
the
ai~
valve
dampers; top~up
if
necessary.
2. Control
linkages:
Apply
a few drops
of
engine
oi
I to the acce I era
tor
Ii
nkage and gear range
selector
controls
adjacent
to the
transmission
casing.
3.
Electrical
system: Check
all
interior
lamps,
exterior
lamps, instruments, warning lamps and
devices
for
correct
operation.
Rectify
as
necessary.
4.
Handbrake
linkage:
Lubricate
the
pivot
pins
and
pulleys
with
approved grease.
5.
Tyres:
Check the tread depth
of
all
tyres,
including
the spare.
Inspect
for
signs
of
damage
and
check
all
five
tyre pressures when
cold.
Adjust
if
necessary.
6.
Test:
Road
test
the
car
for
satisfactory
performance.
Every 40
000
kilometres (24 000
miles)
or
2
years
whichever
is
the
earlier
1. Control
linkages:
Apply
a few drops
of
engine
oil
to the
accelerator
linkage
and gear range
selector
controls
adjacent
to the
transmission
casing.
2.
Electrical
system: Check al I
exterior
lamps,
interior
lamps, instruments, warning lamps and
devices
for
correct
operation;
rectify
as
necessary.
3.
Fuel
filter:
Clean out the f i I
ter
bowl and
tit
a new
filter
element.
4.
Fuel
tank: Slacken the drain
plug
one
or
two
turns and
allow
any accumulated
water
to
drain
away.
Tighten
the
drain
plug.
5.
Height
control mechanism:
Disconnect
the
control
valve
linkage
ball
joints.
Clean, grease and
refit.
6.
Handbrake Ii nkage:
Lubricate
the
pivot
pins
and
pulleys
in
the handbrake system
with
approved
grease.
7.
Spare wheel
carrier:
Lubricate
the spare
whee
r
carrier
lowering
bo
It
and mechanism.
8.
Tyres:
Check the tread depth
of
all
tyres,
including
the spare.
Inspect
for
signs
of
damage
and check
al
I
five
tyre
pressures when
cold.
Adjust
if
necessary.
9.
Test:
Road
test
the car for
satisfactory
performance.
Servicing
after
40
000
kilometres
(24
000
miles)
or 2 years whichever
is
the
earlier
After
40
000
kilometres
(24
000
mi I es)
or
2
years,
servicing
is
still
due
at
the
following
intervals.
E10
~
4
50
000 kilometres (30 000 miles)
or
2'h years
whichever is
the
earlier
Carry
out
the 10 000 km.(6
000
miles)
service.
60
000
kilometres
(36 000
miles)
or
3 years
whichever is the earlier
Carry out the
20
000
km.(12
000
miles)
service.
70 000
kilometres
{42 000
miles)
or
31/2
years
whichever is the earlier
Carry
out
the 10
000
km.(6
000
miles)
service.
80
000 kilometres (48 000 miles)
or
4 years
whichever is
the
earlier
Carry
out
the
40
000
km.(24
000
miles)
service.
Seasonal Schedules
Every
12
months
1.
Engine
cooling
system:
Drain
off
the
old
coolant and
fill
the system
with
fresh
anti-freeze,/
water
mixture
or
inhibited
solution.
Just
prior
to
the
Autumn, clean any
debris
from the
surfaces
of
the
refrigeration
condensers and
radiator
matrices
by
reverse
flushing
with
a
hose.
2.
Air
con di
ti
oni
ng
system: Check
that
the foam
filter
element
in
the
scuttle
intake
grille
is
free
from
obstruction;
fit
a
new
element
if
necessary.
On
Long
wheelbase
cars
fitted
with
a
centre
division
ensure that the foam
filter
element
fitted
below
the rear
refrigeration
system
air
intake
gri
I
le
is
free from
obstruction.
Fit
a
new
filter
element
if
necessary.
3.
Body
drain
holes:
Ensure
that
the body
drain
holes
are not
obstructed.
Every 2 years
In
addition
to the 12
monthly
schedule, carry
out
the fol
lowing.
1.
Engine
cooling
system:
Drain
the
coolant
from the
radiator
and
engine
crankcase.
Thoroughly
reverse
flush
the
coolant
passages
with
a
continuous
flow
of
water.
Change
the
coolant
hoses
where necessary.
Fi
II
the system
with
the
correct
anti
•freeze
mixture.
Service Recommendations
Every
80
000
kilometres (48 000 miles)
At
this
mi I eage and under normal motoring
conditions
it
is
recommended that the
following
servicing
is
carried
out.
Hydraulic
systems
Renew the front and rear
accumulator
to frame
connector
block
hoses.
Examine the
sub-frame
to brake
caliper
hoses
for
chafing
or
surface
cracking;
renew
if
necessary.
Every 160 000 kilometres (96 000 miles)
At
this
mileage
and
under
normal motoring
conditions
it
is
recommended
that
the
following
servicing
is
carried
out.
To Next Page
Loading...
