Page - 2 -
© 2014
SLF 2250/4000
Hydromatic Stinger
Table of Contents
Table of Contents
Table of Contents...................................................................... 2
Introduction .............................................................................. 3
Manufacturer and After-Sales-Service Address ....................... 3
List of Conventional Signs ........................................................ 4
Technical Data ......................................................................... 6
Technical Description ............................................................ 18
Preparation for Use................................................................ 49
Engaging the Water Pump...................................................... 50
Engaging the Hydraulic Oil Pumps ....................................... 52
Tank Suction Operation.......................................................... 53
Drafting Operation from Open Water Source ........................ 54
Hydrant / Supply Operation ................................................... 56
Pump Pressure Governor ....................................................... 58
Foam Operation ..................................................................... 59
Watch out during Pump Operation ........................................ 62
Disengaging the Pump System ............................................... 63
Stinger and Stinger Turret Operation .................................... 64
Roof Turret RM 60 C .............................................................. 71
Rapid Intervention System ...................................................... 76
Filling the Water Tank via the Pump...................................... 77
Filling the Water Tank via Tank Supply Lines ....................... 78
Filling the Foam Compound Tank ......................................... 79
Compressed Air Supply .......................................................... 81
Emergency control of Electro Pneumatic Solenoids .............. 81
Emergency Control of Pneumatic Actuators .......................... 83
Flushing after Foam Operation.............................................. 84
Drainage of the Pump System /
Operation in Cold Climates.................................................... 89
Checking Procedures.............................................................. 92
Maintenance Procedures ........................................................ 95
Service Procedures ................................................................. 97
Problems and their Solutions ............................................... 106
Safety Instructions for Hydraulic Installations .................... 107
Handling and Storing Electronic Components..................... 109
Tilting of Cabin..................................................................... 111
Repetitive Test Cycle for Electrical Components ................. 112
Hints for Disposal................................................................. 113
Annex
Safety Precautions
Piping Diagram
Stinger operation manual
To Next Page