Segway Gokart Kit - User Manual

Ninebot Gokart Kit User Manual
Welcome
WARNINGS
Thanks for choosing the Ninebot Gokart Kit, hereinafter referred to as the Gokart Kit.
The Gokart Kit is an accessory developed specifically for the Ninebot by Segway products listed below. When the Gokart Kit is attached to the appropriate Ninebot by
Segway product it becomes an electric Gokart. You must read and follow these instructions as well as the instructions provided with the applicable Ninebot by Segway
product.
The Gokart Kit is only suitable for use with the Ninebot by Segway
miniPRO (hereinafter collectively referred to as the miniPRO) and
Ninebot S.
Other Ninebot and Segway self-balancing models are not supported.
1
2
3
Packing List & Diagram
Frame
1
User Manual & Limited Warranty
2
miniPRO Adapter Pad
miniPRO adapter pad
3
Hex Wrenches
4
Tools provided to remove the steering
bar bracket
6
Steering wheel quick
release components
7
Power extension cord
8
4mm 5mm
6 (AA) Batteries
5
miniPRO Ninebot S
Ninebot by Segway miniPRO and Ninebot S
are sold separately. Please contact your
reseller for more information.
User Manual Limited Warranty
Riding Safety
V 1.0
www.segway.com
1. The Gokart is a recreational product. Before mastering riding skills, you need to practice. Neither
Ninebot (Ninebot (Beijing) Tech Co., Ltd. or its subsidiaries and affiliates) nor Segway Inc. is responsible
for injuries or damage caused by a driver's inexperience or failure to follow the instructions in this User
Manual or in the New Rider Tutorial.
2. Remember as with any mode of transportation, that whenever you drive the Gokart, you risk injury or
death from loss of control, collisions, and falls. You can reduce the risk by following all the instructions
and warnings in this manual, but you cannot eliminate all the risks.
3. The Gokart kit contains small parts which can create a choking hazard. Keep small children away
from the Gokart.
Pre-Ride Checklist and Preparing for Your Drive:
1. Before each drive check and tighten any loose parts, fasteners, straps, and replace damaged
components.
2. To avoid accidents caused by improperly inflated or worn tires, check the tire pressure on the
miniPRO tires and wear on all tires before each ride. Do not touch moving or spinning tires.
3. Ensure that the battery level and vehicle operating status are within the specifications contained in
the manual of the model being used with the Gokart Kit.
4. Carefully read, understand and follow all instructions in this User Manual and watch and understand
the New Rider Tutorial in the App before your first drive. Do not attempt to drive the Gokart if you are
not able to drive in accordance with the instructions in this Manual or you risk serious injury or death.
5. Always wear appropriate shoes, clothing, and protective gear when riding. Protective gear includes
the use of a helmet, knee pads, and elbow pads (not included). Use an approved bicycle or skateboard
helmet that fits properly with the chin strap in place, and provides protection for the back of your head.
Remove or tie back anything loose (i.e. clothing, hair, jewelry, etc.) that could be caught in any moving
parts. Always fasten the seat belt before riding and ensure it is securely tightened. Loose seat belt can
get stuck in the wheels.
6. Do not turn the Gokart on unless it is parked on flat ground.
Where to Drive:
1. When entering public spaces, always comply with the local laws and regulations. Only ride in areas
where you have first obtained permission from the property owner.
2. The Gokart is designed to be driven on a dry, flat, hard-surface, free of obstacles, bumps, holes, and
other hazards.
3. The kinds of surfaces which are appropriate for safe use of the toy.
4. Do not drive on roadways, near motor vehicles, pedestrians, bicyclists, animals, on or near steep
inclines or steps, curbs, near swimming pools, through puddles or other bodies of water. Use caution
when riding in areas with trees, posts, or fences. You must leave sufficient space between you and those
To reduce the risk of injury, adult supervision is required. Never use in roadways, near motor vehicles, on
or near steep inclines or steps, swimming pools or other bodies of water; always wear shoes, and never
allow more than one rider.
Always fasten seat belt, wear a helmet with long hair tucked inside and wear protective gear. Loose
clothing or hair can become stuck in wheels or block your vision. Wear appropriate closed toed, secure
footwear. No loose clothing.
Do not drive in rain or snow. When not in use, park the Gokart indoors to avoid water entering and
damaging the vehicle.
Comply with all local laws and regulations.
Correct dress code
Wear a helmet
Tie up long hair
(if any)
Zip up the zipper
No long skirts
Wear flat shoes
Wear
protective
gear
No Loose
long Hair
Handbrake
handle
Seat
Steering wheel
Battery compartment
Scalable structure of frame
Throttle (right)
Brake (left)
Status indicator
Headlight
Steering wheel quick release components
Electrical connection
cable plug
Attachment straps
Connection tube
(with frame adjustment marking)
Strap fixing hole
Seat belt
When unpacking your Gokart, please verify that the above items are included in the package. If you are missing any components, please contact your dealer/distributor or nearest service center (see Contact).
Please retain the box and packaging materials in case you need to ship your Gokart in the future.
Always power off your Gokart and unplug the power source before cleaning.
items to be able to safely pass them.
5. The Gokart is never to be ridden indoors.
6. Do not ride the Gokart at night.
7. Do not ride on any ramp or incline that exceeds the maximum slope.
8. Do not ride in the snow, rain, or on roads which are wet, muddy, icy, or that are slippery for any
reason. Do not ride over obstacles (including, but not limited to, sand, loose gravel, or sticks).
Doing so could result in a loss of balance or traction and could cause a collision.
9. Do not allow the Gokart to get wet. You risk damage to the batteries and potential for a fire or
explosion due to a wet battery pack.
How to Drive:
1. As with other vehicles, faster speeds require longer braking distance. Sudden acceleration or
braking on smooth surfaces could lead to wheel slip and collisions.
2. Be cautious and always keep a safe distance between you and others when driving. Be alert and
slow down when entering unfamiliar areas.
3. Do not allow anyone to drive your Gokart on his/her own unless he/she has carefully read this
manual, and followed the New Rider Tutorial. The safety of new riders is your responsibility. Assist
new riders until they are comfortable with the basic operation of the Gokart and make sure each
new rider wears a helmet and other protective gear.
4. To avoid distraction when driving your Gokart, do not use a cell phone, camera, headphones, ear
buds or perform any other activities while driving.
5. Be alert! Scan both far ahead and in front of you. Your eyes are your best tool for safely avoiding
obstacles and low traction surfaces (including, but not limited to, wet ground, loose sand, loose
gravel, and ice). Use caution when transitioning over differing terrain.
6. When approaching or crossing an intersection, road, corner, or gate of any kind, always slow
down and yield to others.
7. Do not drive at unsafe speeds. You must always use good judgment based on your driving skills
and the surrounding environment.
8. Always slow down when turning. Turning at a high speed can cause loss of control, possible
vehicle turn-over, and risk of injury or death.
9. Do not perform stunts of any kind. All four tires must remain on the ground at all times.
10. While driving the Gokart, always remain seated with arms and legs inside the Gokart.
11. Do not carry cargo of any kind.
12. If the Gokart makes an abnormal sound or signals an alarm while driving, stop immediately and
do not use the Gokart or miniPRO until the cause of the noise/alarm has been identified and
corrected. Contact after-sales service for assistance.
Who Should Drive:
The manufacturer recommends drivers be at least 14 years old. Children under the age of 16
should only drive under adult supervision. Always follow these safety instructions:
A. People who should not drive the Gokart include:
i. Anyone under the influence of alcohol, drugs, or intoxicants.
ii. Anyone who suffers from disease that puts himself/herself at risk if he/she engages in
strenuous physical activity.
iii. Anyone whose weight is outside the stated limits (see Specifications).
iv. Pregnant women.
B. The Gokart is intended for one person only.
C. To drive safely, you must be able to clearly see what is in front of you and you must be
clearly visible to others.
D. Drivers must be able to hear the environment around them.
After Each Drive:
1. Park the Gokart on flat ground and power it off. Failure to do so could cause the Gokart to
move when exiting potentially causing injury to you and others around you.
2. Allow the Gokart to cool down before charging. Do not attempt to charge the Gokart, if it,
the charger, or the power outlet is wet. Follow instructions in the miniPRO User Manual.
3. As with any electronic device, use a surge protector when charging to help protect your
Gokart from damage due to power surges and voltage spikes.
4. Only use the charger specified by the manufacturer. Do not use a charger from any other
product.
5. Only use Ninebot or Segway approved parts and accessories. Do not modify your Gokart.
Modifications to your Gokart could interfere with the operation and performance of the
Gokart, which may result in serious injury and/or damage, and could void the Limited
Warranty.
Maintenance and Storage:
1. Be sure the Gokart is powered off before performing any maintenance or when installing or
replacing parts.
2. When installing components, use proper and sufficient force until the component is secure.
If the installation is too loose or too tight, the Gokart may not function properly resulting in
the potential for injury to you or others or damage to, or malfunction of, the Gokart.
3. Install batteries for the Gokart in accordance with the instructions and ensure that the
positive and negative electrodes of the batteries are installed correctly. Only use the
batteries specified by the manufacturer. Do not charge the batteries as this may cause a risk
of fire or explosion. Do not mix old and new batteries. Do not mix alkaline, standard
(carbon-zinc), or rechargeable batteries. When the batteries are dead, purchase and replace
them yourself.
4. Follow all instructions contained in the miniPRO User Manual when performing mainte-
nance on the miniPRO.
5. Do not use a strong water flow or high-pressure hoses to clean the Gokart. Avoid
getting water in the charge port. If your Gokart has been exposed to heavy rain store it
outdoors away from buildings and people but protected from the elements until it is dry.
6. Store your Gokart indoors. The miniPRO should be stored in an environment where the
temperature is no higher than 122°F (50°C) or lower than -4°F (-20°C). If the temperature
of the storage environment is lower than 32°F (0°C), do not charge it until after placing it
in a warm environment (over 50°F (10°C).
The data and parameters of the Ninebot Gokart vary with different models. They are
subject to change without prior notice. Go to www.segway.com for updated information.
Located under the frame. Remove the attachment
strap before removing from the frame.
Risk of death or serious injury from collisions and falls. To reduce the risk of injury user and/or adult must
read and follow the user manual.
Metal mold×2
Used for miniPROUsed for Ninebot S
Metal mold×2 M5 Screw×2 M6 ScrewNut×2 Steering bar bracket
removal tool
Bumper

Summary

Welcome to the Ninebot Gokart Kit

Safety Warnings and Precautions

Correct Dress Code for Riding

Guidelines on attire and protective gear to ensure rider safety while operating the Gokart.

Riding Safety Guidelines

Comprehensive safety rules covering pre-ride checks, driving practices, and general riding environment.

Where and How to Drive

Instructions on appropriate driving locations and fundamental operational techniques for safe Gokart use.

Who Should Drive the Gokart

Driver Age and Supervision Requirements

Specifies recommended age, supervision needs for minors, and conditions disqualifying individuals from driving.

Visibility and Audibility Requirements

Ensures drivers can see and be seen, and can hear their surroundings for safe operation.

Maintenance and Storage Procedures

General Maintenance and Installation

Covers powering off before maintenance, secure component installation, and battery handling.

Cleaning and Indoor Storage

Guidance on cleaning the Gokart safely and storing it indoors under specific temperature conditions.

Gokart Kit Packing List and Diagram

Key Gokart Components

Highlights important parts like the steering wheel quick release and scalable frame structure.

Included Accessories and Tools

Lists essential items like manuals, batteries, tools for assembly, and compatibility notes.

Assembling and Disassembling the Gokart

Preparing the miniPRO for Assembly

Steps to update miniPRO firmware, activate Gokart mode, and pair with the mobile app.

Gokart Assembly Steps

Detailed instructions for attaching the Gokart Kit to the miniPRO, including strap and cable connections.

Disassembling the Gokart

Procedure for safely detaching the Gokart Kit from the miniPRO, including removing the steering bar bracket.

Driving and Charging the Gokart

Activating and Driving the Gokart

Instructions on powering on, using the app, and the basic controls for acceleration, braking, and steering.

Charging the Gokart

Guidance on connecting the charger and important safety notes regarding wet connections.

Gokart Specifications

Certification and Compliance

European Union Battery Recycling

Information on battery labeling and disposal according to EU directives, emphasizing separate collection and recycling.

RoHS Restriction Compliance

Statement of compliance with EU directives restricting hazardous substances in electrical equipment.

Radio and Telecommunications Compliance

Declaration of compliance with EU directives for wireless equipment functionality and safety.

Overview

1. Function Description
2. Usage Features
3. Maintenance Features

This document describes the Ninebot Gokart Kit, a device designed to transform a Segway miniPRO into an electric go-kart. It emphasizes safety, proper assembly, usage, and maintenance to ensure a safe and enjoyable experience.

Function Description

The Ninebot Gokart Kit is an accessory that converts a Segway miniPRO into a fully functional electric go-kart. It allows users to experience the thrill of go-karting with the added benefit of electric propulsion. The kit includes various components such as a steering wheel, seat, frame, and attachments that integrate with the miniPRO to create a complete go-kart. The miniPRO acts as the rear-wheel drive unit, providing power and control to the go-kart. The design focuses on user safety and ease of assembly, making it accessible for a wide range of users. The Gokart Kit is designed for recreational use, offering an exciting way to enjoy the miniPRO beyond its original self-balancing scooter function.

Usage Features

The Gokart Kit offers several features to enhance the user experience. It includes a steering wheel for precise control, a comfortable seat, and a robust frame. The go-kart can be operated in different speed modes, allowing users to choose a setting that matches their skill level and comfort. These modes typically include a beginner mode, a standard mode, and a sport mode, each offering different acceleration and top speeds. The device is equipped with a braking system that combines mechanical and electronic braking for reliable stopping power. The steering wheel includes controls for acceleration and braking, providing an intuitive driving experience.

The go-kart is designed for use on flat, hard, dry surfaces, free from obstacles, loose debris, or slippery conditions. It is not intended for off-road use, racing, or stunts. Users are advised to wear appropriate safety gear, including a helmet, elbow pads, and knee pads, to minimize the risk of injury. The maximum weight capacity and minimum age requirements are clearly stated to ensure safe operation. The device also features a reverse function, allowing users to back up when needed.

The Ninebot Gokart Kit integrates with the Segway-Ninebot app, which provides additional functionalities. Through the app, users can activate the Gokart Kit, access tutorials, monitor device status, and customize settings. The app also allows for firmware updates, ensuring the device remains up-to-date with the latest features and safety enhancements. Users can track their rides, share experiences, and engage with the Ninebot community. The app serves as a central hub for managing the Gokart Kit and enhancing the overall user experience.

The assembly process is designed to be straightforward, with clear instructions provided in the manual. It involves attaching the various components of the Gokart Kit to the Segway miniPRO. The manual includes detailed diagrams and step-by-step instructions to guide users through the assembly, ensuring proper installation and safe operation. Once assembled, the go-kart can be easily disassembled for storage or transport.

Maintenance Features

Proper maintenance is crucial for ensuring the longevity and safe operation of the Ninebot Gokart Kit. The manual outlines several maintenance procedures that users should follow regularly. These include checking the device for any loose parts, damage, or wear before each use. Users are advised to inspect the tires for proper inflation and wear, and to ensure that all connections and fasteners are secure. The braking system should be checked regularly to ensure it is functioning correctly.

Cleaning the device is also an important aspect of maintenance. Users should clean the Gokart Kit with a soft, damp cloth and avoid using harsh chemicals or abrasive materials that could damage the finish. The device should be stored in a dry, cool place, away from direct sunlight and extreme temperatures, to prevent damage to the electronic components and battery.

The battery is a critical component of the Gokart Kit, and its proper care is essential. Users should follow the charging instructions provided in the manual, using only the original charger. The battery should not be overcharged or left discharged for extended periods, as this can reduce its lifespan. If the device is not going to be used for a long time, it is recommended to charge the battery to a certain level (e.g., 50-70%) and store it in a cool, dry place, recharging it periodically to maintain its health.

The manual also provides troubleshooting tips for common issues that users might encounter. These tips help users identify and resolve minor problems, such as connectivity issues with the app or minor operational glitches. For more complex issues, users are advised to contact customer support or a certified service center. Regular maintenance and adherence to the guidelines in the manual will help ensure the Gokart Kit remains in optimal condition and provides a safe and enjoyable experience for years to come.

Segway Gokart Kit Specifications

General

Weight Capacity	220 lbs (100 kg)
Adjustable Frame Length	Yes
Adjustable Steering Wheel Height	Yes
Reverse Function	Yes
Charging Time	4 hours
Assembly Required	Yes
Maximum Speed	24 km/h
Compatibility	Segway Ninebot S
Recommended Age	14+ years
Braking Method	Electronic brake
Operating Temperature	14-104°F (-10-40°C)
IP Rating	IPX4
Weight	28 kg
Adjustable Speed Modes	3
Storage Temperature	-20°C to 50°C