Name: StarTrac 263-4WD-8G-STAGE-V
Brand: StarTrac
Rating: 5 (1 reviews)

To Next Page

OWNER’S MANUAL

263-4WD-8G-STAGE-V

OWNER’S MANUAL -263 - 4WD - 8G - STAGE - V

EDITION - 210312

Table of Contents7
Chapter -1 Tractor Identification13
Vehicle Identification Number (Chassis Number)13
Engine Serial Number14
Rops Certificate Plate14
Universal Symbols15
Chapter -2 Introduction, Warranty & Safety Notes16
Introduction16
Warranty Procedure16
Parts Warning17
If You Move17
Service after Warranty17
Safety17
International Warranty Policy for Eu Tractors18
Mandatory Services to be Availed by Customers to be Eligible for Warranty19
Safety Alert Symbols and Terms20
Safety: Introduction20
Safety: a Word to the Operator21
SAFETY: DANGER, WARNING and CAUTION21
Safety: Decals21
Safety: for Safe Operation22
Safety Frame23
Operation24
Damage to the Safety Frame25
Protect Yourself25
Know Your Equipment25
Use All Available Protective Devices26
Clean the Tractor27
Protect the Environment27
Only for North America27
Servicing the Tractor27
Warn Bystanders before Starting28
Mount and Dismount Properly28
Start Safely28
Follow Safe Operating Practices29
Watch out for Others29
Never Lift a Load over Anyone30
Risk of Overturn30
To Avoid Side Overturns30
To Avoid Rear Overturns31
General Operating Hazards32
Road Transport33
Road Regulations34
Noise Characteristics and Measurement34
Noise Pathologies35
Position of Decals on Tractor36
Chapter -3 Instruments and Controls39
Controls39
Instrument Panel40
Hour Cum Rpm Meter40
Engine Coolant Temperature Guage40
Fuel Level Gauge41
Dashboard41
Combination Switch for Following Operations41
Battery Charging Indicator42
Driver's Seat42
Toolbox43
Under Hood Muffler43
Ignition Key43
Hazard Warning Light Switch43
Head Lights & Taillights44
Plough Light44
Battery Isolator Switch44
Chapter -4 Operation45
Boarding the Tractor45
Leaving the Tractor45
Starting the Engine (in Safety Mode - Neutral Position Only)45
Cold Weather Starting (Temperatures below 0°C or 32°F)45
Running in46
After Starting the Engine46
Stopping the Tractor47
Turning off the Engine47
Opening & Closing the Bonnet47
Accelerator Pedal47
Clutch Pedal47
Gear Shifter Levers48
Shifting Speed Range Selector Lever48
Lever (2Wd / 4Wd)48
PTO (POWER TAKE OFF) Lever49
Precautions When Using the Pto49
Information about Using Implements with Pto Drive Shafts50
Hand Throttle Lever51
Hydraulic Coupling Devices51
Power Steering51
Power Steering Circuit Diagram52
Transport Lock52
Differential Lock53
Service Brake53
Parking Brake53
Parking Brake Release53
Use in Paddy Fields54
Ground Speed Tables54
Wheels and Tyres55
Tyre Pressure in Field Operations55
Tyre Pressure in Road Operations56
Tyre Ballasting56
Mechanically Controlled Power Lift - Hydraulic System56
Position Control (Pc) Lever57
Draft Control (DC) Lever57
Three-Point Linkage57
Adjustable Top Link57
Adjustable Lift Rod or Leveling Rod58
Lateral Stabilizers Chain58
Lower Links58
Hitching Implements58
Unhitching Implements59
How to Safely Drive the Tractor59
Transport the Tractor59
Chapter -5 Maintenance60
Maintenance Schedule60
Sealed Units61
Running in61
How to Prevent Pollution61
Serving Intervals62
Miscellaneous Inspections62
Fuel Injection Pump62
Keep the Environment Clean62
Engine Cooling System62
Radiator62
Lubrication62
Indicator Lights63
Fuel Tank Filling63
Fuel Requisites63
Fueling63
Fuel Storage63
Engine Oil Level64
Recommended Engine Oil Viscosity According to Air Temperature64
Rear Transmission, and Hydraulic Oil Level64
Recommended Gear Oil Viscosity According to Air Temperature65
Front Differential Oil Level65
Radiator Coolant Level (Hot)66
Precautions against Freezing Temperatures66
Replacement of Engine Oil Filter66
Changine and Refilling of Engine Oil67
Replacement of Engine Fuel Filter67
Air Bleeding of Fuel System67
Replacement of Transmission, Rear Final Drives and Power Lift Hydraulic Circuits Oil68
Radiator Draining & Flushing (When Cold)68
Radiator Fins Cleaning69
Radiator Cap69
Check or Replace Hose Pipes69
Dry Type Air Filter69
Important Instructions for Air Filter70
Cleaning of Suction Strainer70
Steering Cylinder Knuckle70
Clutch Pedal71
Method to Check Clutch Pedal Free Play71
Method to Adjust Clutch Pedal Free Play71
Brake Pedal71
Method to Check Brake Pedal Free Play71
Method to Adjust Brake Pedal Free Play72
Parking Brake72
Battery72
Battery Removal Procedure73
Check Electrolyte Level73
Battery Charging Procedure73
Battery Replacement Procedure74
Hazard Related to Battery74
Avoid Battery Hazard by74
If Acid Is Spilled on Skin or in Eyes75
If Acid Is Swallowed75
Alternator (12V, 65A)75
STARTER MOTOR (12V, 1.6Kw)75
Checking V-Belt75
Adjusting V-Belt Tension75
Miscellaneous Inspections76
Dashboard Control Coatings76
Fuses76
Seven Pin Socket for Trailer76
Connection for Seven Pin Socket77
Long Idle Period77
Greasing Points Available on the Tractor78
Greasing Points79
Wiring Circuit Diagram80
Chapter -6 Technical Specification81
Overall Dimension82
Chapter - 7 Do' and Don'ts83
Chapter - 8 Trouleshooting87
St SERVICE COUPON90
Nd Service Coupon92
Rd Service Coupon94
Th Service Coupon96
Th Service Coupon98

Questions and Answers:

Need help?

Do you have a question about the StarTrac 263-4WD-8G-STAGE-V and is the answer not in the manual?

StarTrac 263-4WD-8G-STAGE-V Specifications

General

Brand	StarTrac
Model	263-4WD-8G-STAGE-V
Category	Tractor
Language	English

StarTrac 263-4WD-8G-STAGE-V User Manual

Table of Contents

Questions and Answers:

StarTrac 263-4WD-8G-STAGE-V Specifications