Stihl HSA 60 User Manual (English)

Questions and Answers:

M
Monica CooperJul 29, 2025
Why won't my Stihl HSA 60 start?
- M
  Melissa JonesJul 29, 2025
  Your Stihl Trimmer might not start due to several reasons: there may be no electrical contact between the trimmer and the battery (remove the battery, visually check the contacts, and reinsert it); the battery may have low charge (charge the battery); the battery may be too hot or cold (allow it to warm up or cool down); there may be a malfunction in the battery (remove and reinsert it – if the LEDs continue to flash, replace it); the trimmer may be too hot (allow it to cool down); there may be a malfunction in the trimmer (remove and reinsert the battery – if the LEDs still flash, have it checked by a servicing dealer); or the cutting blades may not be clean and lubricated (clean the cutting blades – if the LEDs still flash, have it checked).
F
fred15Aug 4, 2025
Why does my Stihl Trimmer cut out while I'm using it?
- S
  stonesamanthaAug 4, 2025
  Your Stihl Trimmer might cut out during operation if the battery is too hot or too cold (remove the battery and allow both the trimmer and battery to cool down or warm up gradually) or if the hedge trimmer itself is too hot.
J
jademiddletonAug 10, 2025
What to do if the LED on my Stihl Trimmer charger flashes red?
- E
  Erik GrimesAug 10, 2025
  If the LED on your Stihl Trimmer charger flashes red, it could be due to a few reasons: there might be no electrical contact between the charger and the battery (remove and reinsert the battery into the charger); there could be a malfunction in the battery (remove and reinsert it – if the LED continues to flash, and if 4 LEDs on the battery are flashing, replace the battery; otherwise, have it checked by a servicing dealer); or there may be a malfunction in the charger (have the charger checked by a servicing dealer).
O
othompsonAug 16, 2025
Why is my Stihl HSA 60 Trimmer battery not charging when the charger LED is green?
- E
  elizabethortizAug 16, 2025
  If your Stihl Trimmer battery isn't charging even though the LED on the charger is green, the battery might be too hot or too cold. Allow the battery to warm up or cool down gradually. Operate the charger indoors in a dry room.
M
Mr. Tyler PattersonAug 22, 2025
How to fix a Stihl HSA 60 charger that won't run a self-test?
- C
  Christopher RasmussenAug 22, 2025
  If the charger for your Stihl Trimmer does not run a self-test, it may be because the electrical contact to the charger was briefly interrupted. Disconnect the plug from the electrical outlet, wait one minute, and then reinsert the plug into the outlet.

Stihl HSA 60 Specifications

General

Brand	Stihl
Model	HSA 60
Category	Trimmer
Language	English

Summary

Introduction

Guide to Using this Manual

Explains how to use the manual, including signal words and symbols.

Product Components and Symbols

Main Parts Overview

Identifies and describes the main components of the hedge trimmer, battery, and charger.

Product Safety Symbols

Shows and explains safety symbols found on the product.

General Power Tool Safety

Work Area and Electrical Safety

Covers safe work areas, electrical precautions, and avoiding hazards.

Personal and Battery Safety

Emphasizes operator alertness, PPE, battery use, and service.

Hedge Trimmer Specific Safety

Outlines safety precautions specific to hedge trimmer operation.

Important Safety Instructions

Intended Use

Specifies light-duty home use and warns against misuse.

Operator Safety

Stresses operator health, alertness, and avoiding distractions.

Personal Protective Equipment

Details necessary PPE like eye protection and clothing.

Hedge Trimmer Safety

Covers risks like electric shock and blade contact.

Using the Hedge Trimmer Safely

Covers safe operation, holding, conditions, and before/after use procedures.

Battery Safety

Battery Warnings and Instructions

Warns against unauthorized batteries/chargers, extreme temperatures, and short circuits.

Charger Safety

Charger Warnings and Instructions

Covers risks of fire, electric shock, and damage from improper charger use.

Maintenance, Repair, and Storage

Maintenance and Repair Precautions

Warns against unauthorized repairs and emphasizes safe practices.

Pre-Operation and Charging

Preparing for Operation

Details tasks like charging the battery and checking controls before starting.

Charger Setup and Charging

Instructions on charger setup, charging process, and wall mounting.

LED Diagnostics

Battery and Trimmer Status LEDs

Explains how LEDs indicate battery charge, temperature, and trimmer malfunctions.

Charger LED Indicator

Explains the meaning of the single charger LED.

Adjusting the Hedge Trimmer

Rotating the Control Handle

Details how to rotate the control handle for ergonomic positioning.

Battery Insertion and Removal

Inserting and Removing the Battery

Steps for correctly inserting and safely removing the battery.

Switching the Hedge Trimmer On/Off

Switching On and Off

Guides on safe procedures and steps to switch the hedge trimmer on and off.

Checking the Controls

Testing Controls

Explains how to test the trigger switch lockout, ergo-lever, and trigger switch.

During Operation

Using the Hedge Trimmer

Provides guidance on safe hedge trimming, including operation and cutting techniques.

Post-Operation Procedures

Preparing for Transport/Storage

Steps to prepare the trimmer for transport or storage, including cleaning.

Transporting Equipment

Hedge Trimmer, Battery, and Charger Transport

Safety precautions and methods for transporting all equipment components.

Storing Equipment

Storing Trimmer, Battery, and Charger

Advice on storing all equipment components securely and correctly.

Cleaning Procedures

Cleaning the Trimmer, Battery, and Charger

Details how to clean the trimmer, battery housing, and charger.

Cleaning the Cutting Blades

Instructions for cleaning cutting blades with a resin solvent.

Inspection and Maintenance

Maintenance Schedule and Tasks

Provides a chart outlining recommended inspection and maintenance intervals.

Hedge Trimmer Maintenance

Covers lubricating the gearbox and sharpening blades.

Gearbox Lubrication

Lubricating the Gearbox

Step-by-step guide on how to lubricate the gearbox.

Cutting Blades Maintenance

Inspecting and Maintaining Cutting Blades

Instructions on inspecting and sharpening the cutting blades.

Troubleshooting Guide

Trimmer and Battery Issues

Lists common problems with the trimmer and battery and their solutions.

Charger Troubleshooting and Specifications

Charger Issues and Specifications

Details charger issues, specs for HSA 60, blades, and AK battery.

AL 101 Charger and Temperature Specs

Lists AL 101 charger specs, temperature limits, and recommendations.

Product Symbols and FCC Compliance

Explains product symbols and FCC compliance statement.

Replacement Parts and Disposal

Genuine Replacement Parts

Recommends using genuine STIHL replacement parts and how to identify them.

Equipment Disposal and Recycling

Directs users to approved disposal sites and battery recycling.

Warranty and Addresses

Limited Warranty Policy

Refers to the STIHL Incorporated Limited Warranty Policy.

STIHL Incorporated Contact Address

Provides the postal address for STIHL Incorporated.

Related product manuals