Suburban SF-30F User Manual

SUBURBAN MANUFACTURING COMPANY
676 Broadway Street
Dayton, Tennessee 37321
USER’S INFORMATION MANUAL
For Models
SF-20 • SF-25 • SF-30 • SF-35 • SF-42
SF-20F • SF-25F • SF-30F
SF-35F • SF-42F
SFV-20 • SFV-25 • SFV-30 • SFV-35
SFV-42
SFV-20F • SFV-25F • SFV-30F
SFV-35F • SFV-42F
SH-35 • SH-42 • SH-35F • SH-42F •
SHD-2542
This book contains instructions covering the operation and
maintenance of your furnace. Keep with unit at all times.
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFRENCE.
Should you require further information, contact your dealer or nearest
Suburban Service Center.
WARNING! Installation of this appliance
must be made in accordance with the
written instructions provided in this
manual. No agent, representative or
employee of Suburban or other person
has the authority to change, modify or
waive any provision of the instructions
contained in this manual.
WARNING! Improper installation,
adjustment, alteration, service or
maintenance can cause property damage,
personal injury or loss of life. Refer to the
installation instructions and/or owners
manual provided with this appliance.
WARNING! Be sure the furnace and all
ignition systems are “OFF” during any
type of refueling and while vehicle is in
motion or being towed.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or loss of life.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
• Extinguish any open flame.
• Evacuate all persons from the vehicle.
• Shut off the gas supply at the gas
container or source.
• Do not touch any electrical switch, or
use any phone or radio in the vehicle.
• Do not start the vehicle’s engine or
electric generator.
• Contact the nearest gas supplier or
qualified service technician for repairs.
• If you cannot reach a gas supplier or
qualified service technician, contact the
nearest fire department.
• Do not turn on the gas supply until the
gas leak(s) has been repaired.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.

Suburban SF-30F Specifications

General

BTU Output	30, 000 BTU
Type	Forced Air
Ignition	Direct Spark Ignition
Voltage	12V DC
Fuel Type	Propane
Efficiency	80%

Summary

User's Information Manual and Safety

Applicable Furnace Models

Lists the specific Suburban furnace models covered by this manual.

Critical Safety Warnings

Provides essential safety precautions regarding operation, gas, and potential hazards.

Maintenance and Cleaning

General Maintenance Precautions

Outlines essential user responsibilities for safe furnace operation and longevity.

Burner Flame Observation

Guides on how to visually inspect the burner flame for correct operation.

Yearly Service Inspection

Details critical checks recommended for annual servicing by a qualified agency.

Operating Instructions

Pre-Operation Safety Checks

Essential steps and warnings before starting the furnace operation.

Furnace Operation Procedure

Step-by-step guide for safely starting and operating the furnace.

Turning Off Gas Supply

Procedure for safely shutting off the gas supply to the appliance.

Warranty and Product Support

Limited Warranty Terms

Details the two-year limited warranty and three-year heat exchanger warranty.

Warranty Limitations and Exclusions

Lists conditions and exclusions that are not covered by the warranty.

Product Problem Resolution

Provides steps for addressing product issues and obtaining service.