SunPower PERFORMANCE P6-COM-S-BF - Page 10

MAXEONSOLARTECHNOLOGIES,LTD.
SafetyandInstallationInstructions‐Document001‐15497Rev.W
©December2021MaxeonSolarTechnologies,Ltd.Allrightsreserved.Specificationsincludedinthismanualaresubjecttochangewithoutnotice.

5) Maxeon specified or Maxeonsupplied mounting systems.
Modules mounted with strict adherence to Maxeon
documentation, using hardware systems supplied by or
specifiedbyMaxeon.

Figure2andTable1.1belowdemonstratethemountinglocationsand
Tables1.2and1.3giveallowedloadratings(designedtestvalue)for
Maxeonmodules.
Figure2:MountingZonelocationsforMaxeonmodules 
ForP‐Series,MAX396,104,112cellsandMAX666cells:

For128cells,P‐SeriesandMAX5/MAX6Commercial:

Table1.1:Approvedmoduleclamping/directfixationzones
ModuleConfiguration
Mountingzonedistancefrom
cornerin(mm)
1

Frame
holes
E
Modulesize
Frame
type
A B C
(1&2&3&4)

(1&2&3&4)

(1&2&3&4)

(1&2&3&4)

96cells,104
cells(MAX2,
MAX3),112
cells,P3BLK
andP3RES+

G3
(Black)
Silver&
G4.1&
G4.2&
G4.3
50‐350

150‐380

50‐150


Asper
Drawingin
theTable2
128cellsand
P19‐COM
G4&
G4.1&
G4.2
50‐350 408‐880 50‐375
P3‐COM
G4.2&
G4.3
50‐350 408‐833 50‐375
MAX6(66cells) G5.2 50‐350 265‐514 50‐265
MAX5and
MAX6COM
(72cells)
G4.2&
G5.6
50‐350 296‐536 50‐296
D‐Thereisa20mmzoneat388‐408mmfromthecornerwheremountingisnot
allowedduetothemodulestackingpinfeature.Applicableto128and96cell
commercialonly.
1) Nopartofthemoduleclampmayextendbeyondthisarea.



Figure3:MountingConfigurations
Configurations1and2showmountingwithrailsupport,3and4
showmountingwithoutrailsupport.In“WithRailSupport”therails
becomesconventionalorrailstransversewhile“WithoutRail
Support”becomesendmountedinlongorshortside.Inthecase
whentheglassdeflectsitwouldnotdeflectintherailsforadditional
support.
Table1.2: MountingZoneDesignLoadRatingsfor Rackingsystem
withoutrailsupportunderneaththemodule.Refertoconfiguration
3and4inFig.3
Module
Configuration
Wind(up&down)/Snow(down)
(unitsinPa)(***)
Module
size
Frame
type
End
Mount

A

(1&2&3&4)

Frame
Holes
E
(1&2&3&4)

B
(1&2&3&4)

C
(1&2&3&4)

orB+C
(B
1&3
+C
2&4
or

B
2&4
+C
1&3
)
OrA+B
(A
1&3
+B
2&4
or

A
2&4
+B
1&3
)
OrA+C
(A
1&3
+C
2&4
or

A
2&4
+C
1&3
)
96cells,
andP3BLK
G3
Black&
Silver&
G4.1&
G4.2&
G4.3

2400/
2400
(*)



2400/
5400


2400/
5400


2400/2400

104cells
(MAX2,
MAX3)and
112‐cells
(MAX3)
G4.2
1800/
1800
P3RES+ G4.3
1300/
1600
1600/
2400
1600/
2400
1300/
1600
128cells,
P19‐COM
G4&
G4.1&
G4.2
Not
applicable
(**)
2400/
5400
3600/
3600
2400/2400
P3‐COM
G4.2&
G4.3
1600/
1600
1600/
2400
1600/
2400
1600/1600
MAX6(66
cells)
G5.2
1600/
1600
3600/
3600
3600/
3600
1600/1600
MAX5‐
COM
(72cells)
G4.2
1600/
1600
3600/
3600
3600/
3600
1600/1600
MAX6‐
COM
(72cells)
G5.6
1067/
1200
(*):5400Paisallowedwithclampsandmountingrailsalongthelongersideoftheframe
(**):2400/2400Paareallowedwithclampsandmountingrailsalongthelongersideof
theframe
ForRooftopapplication1200/1200Paisallowedwithonlyclamps
(***)Safetyfactorof1.5included











