SUNWIND DISA 440526 - Maintenance and Warranty Information; Curing Cast Iron Grids; Regular Maintenance; Warranty Terms

English
How to cure Disas cast iron grids
Thecastirongridsshouldbewashedwithdilutedsoapwaterpriortousagetoremovepossible
remnantsofgreaseand/oroilfrommanufacturing.Wipedry,thenthreatbothsidesofthegrids
withcookingoil.Re-installthegrids,turnontheburnersandleavethemburninginalowposion
for15-20minutes,orunlitstopsoozing.
Burningatmaximumheatforapprox.10minutesisrecommendedaereachuse,tocleanthe
castirongrids.Remnantsoffoodandsotarethenremovedusingasteelbrush,whichcanbe
obtained from your supplier or on Sunwind.no.
NOTE:ThegridsshouldalsobesaturatedwithoilaerusageandiftheBBQisnottobeusedfor
alongerperiodofme.Failuretodothiswillresultinalayerofrustonthesurface
Maintenance
YourBBQshouldbekeptcleannottodeteriorate.Thesurfacewillneedsimilartreatmenttothat
ofacar,andtheBBQshouldbeprotectedbyaedcoverwhenstalled.Thecover’Regnfrakk’
canbeboughtonSunwind.noorSunwindgrill.dk.
CleanDisathoroughlyonaregularbasis:takeoutallgrids,ametamersandburnersandclean
those,washallsurfacesandalllilecornersandaerwardscoveritwithathinlayerofneutraloil
(acidfreeoil).Oilsusedforsowingmachinesorweaponsaresuitable.Movablepartssuchasthe
hinges,wheelnutsanddoorsshouldbesprayedwithalubricant.
Theburnersalsoneedmaintenance.Keepthesecleanbybrushingthemandassurethattheholes
arekeptopenandfreeofdirt.Thecastirongridsshouldbecoveredwithcookingoilafewmes
perseasonandalwaysattheendofeachseason–beforestallingtheBBQforalongerperiodof
me!
Warranty
Disahasa10yearwarrantyprogram,thewarrantyalsoappliestoperforaon.Thiswarrantydoes
notcoverburners,ametamers,greasetrayandgridsasthesepartsaredenedaswearparts.
Forthewarrantytobevalid,itrequiresmaintenance,asstatedinthemanual.Misappropriaon
andlackofmaintenancecouldresultinparalorfulllossofwarranty.Inthecaseofsurfacecover,
thisisnotcoveredbythewarranty.
Lackofmaintenancethatresultsinfatburningresultsinlossofwarranty.
Thecombinaonofgrease,saltsandheatprovidesanenvironmentthefeweststeeltypesare
resistantto.Inaddion,mostgrillsarestoredoutsideandmoistureandvaryingairtemperatures
alsohaveaninuence.
29