MAINTENANCE
SUMMARY CHART
The Summary Chart below lists general recommendations for Service Operations and Intervals. Overseas Service Engineers are
advised
to
consult the 'Passport to Service' booklet supplied with the car for amendments to these recommendations that
may be specially applicable to their local operating conditions
OR
that may be obligttory
to
meet Regulations for a specific
Country.
ENGINE COMPARTMENT
Operation Number
Interval in miles x 1,000
Interval in Kilometres x 1,000
Operation Description
10.10.03
1
1'6
10.10.06
3
5
10.10.12
6
10
10.10.24
12
20
I.
Check/top up engine oil level (E) X .
2. Check/top up cooling system (E)
X X X X .
3. Check/top up brake fluid reservoir.. X X x X .
4. Check/top up clutch fluid reservoir.. X X X X .
5. Check/top up windscreen washer fluid reservoir X X X X .
6. Check/top up battery X X x X .
7. Check/top up carbl}retter piston(s) damper(s)(E) X X X .
8. Drain engine oil and refill (E) X X X
..
9.
Renew
oil
filter element (E) X .
10. Clean fuel pump sediment bowl X X .
II.
Lubricate distributor and check automatic advance (E) X X X
..
12. Check/adjust/report condition
of
distributor points (E)
J<
X
..
13. Distributor points - renew (E) X .
14. Check/adjust ignition timing using electronic equipment (E) X X X
..
15. Check/report ignition wiring for fraying, chafing and
deterioration (E)
J<
x X .
16. Condensor and coil check for breakdown on oscilascope
tune (E) X
X
..
17. Clean/adjust sparking plugs (E) X .
18. Renew sparking plugs (E) :
X
..
19.
Check/adjust torque
of
cylinder head nuts/bolts (E)
J<
.
20. Check/report cylinder compression (E) X X
..
21. Check/adjust
valve
rocker clearances (E)
J<
.x
.
22. Clean engine oil filler cap (E) X
..
23. Clean carburetter air cleaner elements (E) x
..
24. Renew carburetter air cleaner elements (E) X .
25. Check/adjust/report condition
of
all driving belts (E) X X X : X
..
26. Check security
of
starter motor and alternator retaining
bolts
J<
.
27. Check security
of
engine mountings X .
28. Check/adjust carburetter settings (E) X X X .
29. Carburetter - overhaul - at 24,000 miles (E)
..
30. Fuel filter - change (E) X .
31. Fuel system - check for leaks (E)
J<
X
..
32. Lubricate accelerator linkage/pedal fulcrum and check
operation
J<
X X .
33. Check battery condition: clean and grease connections X X
..
34. Check/report for oil/fuel/fluid leaks (general) (E) X X X X .
35. Check/report leaks from cooling and heater systems (E) X X X ..
36. Evaporative and crankcase ventilations systems
.-
check
hoses and restrictors for blockage, security and
deterioration (E) X
X .
37. Carbon canister - renew filter (E) X
..
38. Carbon canister - renew
48,000
miles (E) ..
39. Lubricate w'ater pump
X .
10.00.02
Triumph
TR6
Manual.
Part
No.
545277 Issue 1
To Next Page
Loading...
