EasyManua.ls Logo

Uniflame GBC1103W - User Manual

Uniflame GBC1103W
24 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Outdoor LP Gas Barbecue Grill
Model No. GBC1103W
Manufactured in China for: Blue Rhino Global Sourcing, Inc
Winston-Salem, NC USA • 1.800.762.1142, www.bluerhino.com
© 2011 Blue Rhino Global Sourcing, Inc. All Rights Reserved
UniFlame
®
is a Registered Trademark of Blue Rhino Global Sourcing, Inc.. All Rights Reserved. GBC1103W-OM-101 ES
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Insert LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Secure LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Connect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Disconnect LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operating Main Burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
The use and installation must conform with local codes or, in the absence of local
codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas
and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA
Z240 RV Series, Recreational Vehicle Code, as applicable.
California Proposition 65: Combustion by-products produced when using this product
contain chemicals known to the State of California to cause cancer, birth defects, and
other reproductive harm.
California Proposition 65: Wash your hands after handling this product.
OWNER’S MANUAL
Made from 75% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
WARNING
FOR YOUR SAFETY:
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
DANGER
Never operate this appliance unattended.
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.

Table of Contents

Questions and Answers

  • R
    Robert HallAug 19, 2025
    What to do if Uniflame GBC1103W burner will not light with match?
    • V
      Veronica WoodAug 20, 2025
      If your Uniflame Barbecue grill burner won't light with a match, there could be several reasons. First, check if there's no gas flow, which could mean the LP gas tank is empty; replace or refill it if needed. Also, make sure that the coupling nut and regulator are fully connected by hand-tightening them. There may be an obstruction of gas flow, so clear the burner tubes and check for any bent or kinked hoses. Ensure the burner is properly engaged with the valve. Finally, inspect for spider webs or insect nests in the venturi, and clean the venturi and burner tube if necessary. Clean burner ports if they are clogged or blocked.
  • M
    molsonAug 22, 2025
    Why is there a sudden drop in gas flow in my Uniflame GBC1103W Barbecue grill?
    • A
      Alexa HollandAug 22, 2025
      A sudden drop in gas flow or reduced flame height in your Uniflame Barbecue grill can happen for a couple of reasons. The most common is simply running out of gas, so replace or refill the LP gas tank. It's also possible that the excess flow safety device has been activated. To reset it, turn all control knobs to the off position, wait 30 seconds, and try lighting the grill again. If the flames are still too low, turn the control knobs off, close the LP gas tank valve, disconnect the regulator, turn the control knobs to high, wait one minute, turn the control knobs off, reconnect the regulator (and check for leaks), and then light the grill according to the lighting instructions.
  • T
    taylorgregoryAug 26, 2025
    How to fix flame blow out on Uniflame GBC1103W Barbecue grill?
    • J
      Jacob RoyAug 26, 2025
      Flame blow out on your Uniflame Barbecue grill can be due to a few reasons. High or gusting winds can cause the flame to extinguish, so avoid using the grill in such conditions. Also, check if you are low on LP Gas and replace or refill the LP gas tank if needed. In case of excess flow valve tripped refer to “Sudden drop in gas flow or reduced flame height”.
  • D
    Diane StoutAug 28, 2025
    Why is the flame yellow or orange on my Uniflame Barbecue grill?
    • S
      Samuel TaylorAug 28, 2025
      A yellow or orange flame on your Uniflame Barbecue grill could be due to several factors. If it's a new burner, it might have residual manufacturing oils, so burn the grill for 15 minutes on high with the lid closed. Another cause could be spider webs or insect nests in the venturi, so clean the venturi. Food residue or grease on the burner can also cause this issue, so clean the burner. Lastly, check the alignment of the valve to the burner venturi and ensure they are properly engaged.
  • R
    rojasmichaelAug 31, 2025
    What causes flare-ups on a Uniflame GBC1103W Barbecue grill?
    • S
      Stephanie NelsonAug 31, 2025
      Flare-ups on your Uniflame Barbecue grill can occur for a few reasons: Grease buildup can cause flare-ups, so remove and clean all grill parts according to the cleaning and care instructions in the owner’s manual. Excess fat in the meat can also be a culprit, so trim the fat before grilling. Finally, excessive cooking temperatures can lead to flare-ups, so adjust to a lower cooking temperature.
  • L
    lorraine41Sep 3, 2025
    Why is the flame irregular on my Uniflame GBC1103W Barbecue grill?
    • D
      Daniel LawrenceSep 3, 2025
      An irregular flame pattern, where the flame doesn't run the full length of the burner on your Uniflame Barbecue grill, is typically due to clogged or blocked burner ports. Clean the burner ports to resolve this issue.
  • G
    Gwendolyn FordSep 6, 2025
    What causes a persistent grease fire on a Uniflame GBC1103W Barbecue grill and what to do?
    • M
      Michael MedinaSep 6, 2025
      A persistent grease fire on your Uniflame Barbecue grill is usually caused by grease trapped by food buildup around the burner system. To handle it, first turn the control knobs to the off position and close the LP gas tank valve. Leave the lid closed and let the fire burn out. Once the grill has cooled, remove and clean all parts according to the cleaning and care instructions in the owner’s manual.
  • C
    Cathy BryantSep 9, 2025
    What causes flashback (fire in burner tube(s)) in Uniflame GBC1103W Barbecue grill?
    • H
      holtsuzanneSep 9, 2025
      Flashback, or fire in the burner tubes, in your Uniflame Barbecue grill is caused by blocked burners and/or burner tubes. Clean the burners and/or burner tubes to resolve this.
  • C
    Caitlin MoralesSep 12, 2025
    Why is the inside of my Uniflame Barbecue grill lid peeling?
    • D
      Daniel BrownSep 12, 2025
      If the inside of your Uniflame Barbecue grill lid is peeling, it's likely due to baked-on grease buildup that has turned to carbon and is flaking off. If the lid is stainless steel, clean it thoroughly following the cleaning and care instructions. If the lid is coated or painted, clean it thoroughly as well. If, after cleaning, you can see steel, please call Customer Care at 1.800.762.1142.
  • R
    rodriguezjohnNov 15, 2025
    What to do if Uniflame GBC1103W burner will not light using ignitor?
    • L
      leslie03Nov 15, 2025
      If the burner on your Uniflame Barbecue grill won't light with the ignitor, several issues could be the cause. First, ensure the LP gas tank valve is open and the regulator is securely attached. If that's not the problem, the LP gas tank might be low or empty, so replace or refill it. Also, check for any LP gas leaks; if you smell gas, turn the tank valve to “CLOSED,” wait five minutes, and then follow the leak-checking procedure in the owner’s manual. It's also possible that the battery needs replacing, the wires or electrode are covered in cooking residue (clean with rubbing alcohol), or the electrode and burners are wet (wipe dry). Other potential causes include a cracked or broken electrode (replace it), a loose or disconnected wire (reconnect or replace the electrode/wire assembly), a...

Uniflame GBC1103W Specifications

General IconGeneral
BrandUniflame
ModelGBC1103W
CategoryBarbecue grill
LanguageEnglish