6221389 - 02
4
Vitocal 100-AW AM2V Installation, Service and Operating
Safety
Safety, Installation and Warranty Requirements
Fiberglass wool and ceramic fiber materials
The state of California has listed the airborne fibers
of these materials as a possible cancer hazard
through inhalation. When handling these materials,
special care must be applied.
First aid measures
– If eye contact occurs, flush eyes with water to
remove dust. If symptoms persist, seek medical
attention.
– If skin contact occurs, wash affected areas gently
with soap and warm water after handling.
Suppliers of fiberglass wool products recommend
the following precautions be taken when handling
these materials:
– Avoid breathing fiberglass dust and contact with
skin and eyes.
– Use NIOSH approved dust/mist respirator.
– Wear long-sleeved, loose fitting clothing, gloves
and eye protection.
– Wash work clothes separately from other
clothing. Rinse washer thoroughly.
– Operations such as sawing, blowing, tear-
out and spraying may generate airborne fiber
concentration requiring additional protection.
Suppliers of ceramic fiber products recommend the
following first aid measures:
– Respiratory tract (nose and throat) irritation: If
respiratory tract irritation develops, move the person to
a dust free location.
– Eye irritation: If eyes become irritated, flush
Immediately with large amounts of lukewarm water for
at least 15 minutes. Eyelids should be held away from
the eyeball to ensure thorough rinsing. Do not rub eyes.
– Skin irritation: If skin becomes irritated, remove soiled
clothing. Do not rub or scratch exposed skin. Wash
area of contact thoroughly with soap and cold water
(as warm or hot water may worsen the irritation). Using
a skin cream or lotion after washing may be helpful.
– Gastrointestinal irritation: If gastrointestinal tract
irritation develops, move the person to a dust free
environment.
1
WARNING
Inhaling of fiberglass wool and/or ceramic fiber
materials is a possible cancer hazard. These
materials can also cause respiratory, skin and eye
irritation.
Operating and Service Documentation
It is recommended that all product documentation
such as parts lists, operating and service
instructions be handed over to the system user
for storage. Documentation is to be stored near
the heat pump in a readily accessible location for
reference by service personnel.
To Next Page
