Volvo Penta DPS-A - Page 128

Owner's Checklist
Check Before Each Use
Check/
Correct
Fill/
Lube
Adjust/
Tighten
Clean
Change/
Replace
Engine
Cooling System – Check coolant level
(1)
; check
system for leaks
● ●
Engine Oil ● ●
Fuel Pump and System – Check for leaks ●
Sterndrive
Anodes – Check, replace if eroded more than 30% ●
Power Trim/Tilt – Check for proper operation ●
Miscellaneous
Emergency Stop Switch – Check clip and lanyard ●
Power Steering – Check for proper operation;
check hoses and components for leaks
●
Power Steering Fluid – Check level ● ●
Remote Control and Shift System – Check for
proper operation
● ●
1) Fresh water cooled versions
Owner's Checklist
Check Each Month
(1)
Check/
Correct
Fill/
Lube
Adjust/
Tighten
Clean
Change/
Replace
Batteries and Connections – Batteries hold charge;
connections clean and tight
● ●
Drive Unit Oil ● ●
Exhaust Hoses and Bellows – Check for damage,
leaks, and loose clamps
● ●
Bellows, U-joint, and Exhaust – Check for wear,
leaks, and loose clamps
● ●
Propshaft, Propeller, and Hub – Check for damage,
corrosion; lubricate shaft, splines
● ● ●
1) Check/correct these items every month, when the boat is in use (not winterized or in storage)
Maintenance Schedule
126 47701898 12-2010