Walinga AGRI-VAC 5614

To Next Page

5614

6614

7614

7816

TOUGH TO BEAT IN THE LONG RUN

AGRI-VAC Model 5614 to 7816

OPERATOR'S MANUAL

and PARTS BOOK

Main Page

Warranty Registration Form & Inspection Report5
Agri-Vac Warranty6
Serial Number Location8
Table of Contents9
Introduction13
Safety14
General Safety15
Operating Safety16
Safety Around Bins,Silos,Tanks and Boot Pits17
Maintenance Safety18
Hydraulic Safety18
Storage Safety18
Transport Safety19
Tire Safety19
Safety Signs19
Sign-Off Form20
Safety Decal Locations21
Fig. 3-1 Typical Decals (Front Driverside)21
Fig. 3-2 Typical Decals Rear Side of Belt Cover21
Fig. 3-3 Typical Decals for Hydraulic Boom Rotation23
Fig. 3-4 Typical Decals on Receiver Tank23
Fig. 3-5 Intake Nozzle Decal (Typical)24
Fig. 3-6 Decal (with Belt Cover Removed.)24
Operation25
A) OPERATION (for UNITS with ELECTRIC MOTORS)25
Safety25
Commissioning: Installation25
Start-Up25
Soft Start25
Storage25
B) OPERATION ( TRACTOR PTO UNITS)26
To the New Operator or Owner26
Machine Components27
Fig. 4-1 PTO Units in Transport27
Fig. 4-2 Intake Nozzle& Intake Line27
Fig. 4-3 Power Sources27
Break-In28
Pre-Operation Checklist28
Equipment Matching29
Fig. 4-4 Drawbar29
Controls30
Fig. 4-5 Controls30
Attaching/Unhooking32
Fig. 4-7 Drawbar32
Fig. 4-8 Pin Retainer32
Fig. 4-9 PTO Shaft Connected33
Fig. 4-10 Attached to Tractor33
Fig. 4-11 Position of Machine to bin 12Ft (4 M)34
Fig. 4-12 Flex Tube Installation34
Machine Preparation35
Fig. 4-13 Security Latch & Boom Saddle35
FIG.4-14 Swing Boom Extension 180 Deg35
Fig. 4-15 Raising the Boom35
Fig. 4-16 Positioning36
Fig. 4-17 Placement36
Operating37
Fig. 4-18 Starting Machine with Tractor37
Starting Machine with a Tractor38
Fig. 4-19 Unloading from Truck to bin38
Fig. 4-20 Monitor Product Movement Behind Glass Door38
Starting Machine with an Electric Motor39
Fig. 4-21 Airlock Speed Flow Divider and Direction Wheel40
Fig. 4-22 Product in the Window41
Fig. 4-23 in Operation41
Fig. 4-24 Using the Clean-Up Nozzle in the bin42
Fig. 4-25 Nozzle Storage42
Fig. 4-26 Emptying the Pre-Cleaner43
Fig. 4-27 Unloading into Truck43
Fig. 4-28 Seconds to Suffocation44
Transporting45
Fig. 4-29 Security Latch Engaged on Boom Extension46
Storage47
Service and Maintenance48
Service48
Fluids and Lubricants48
Greasing48
Servicing Intervals49
Fig. 5-1 PTO Shaft Lubrication Points49
Fig. 5-2 Drive Belts49
Fig. 5-3 Blower Reservoir Schematics50
Fig. 5-4 Blower Reservoirs (Front)50
Fig. 5-5 Blower Reservoirs (Rear)50
Fig. 5-6 Check the Wearliner in Discharge Cyclone51
Fig. 5-7 Boom Swivel51
Fig. 5-8 Boom Cylinder51
Fig. 5-9 Splined Shaft52
Fig. 5-10 Outboard Bearing52
Fig. 5-11 Blower Reservoirs53
Fig. 5-12 Vacuum Relief Valve53
Fig. 5-13 Pressure Relief Valve53
Fig. 5-14 Cyclone Line Seal54
Fig. 5-15 Flex Hose Seals54
Service Record55
Belt Tension and Alignment56
Fig. 5-17 Belt Deflection57
Fig. 5-18 Adjusting Bolts57
Fig. 5-19 Pulleys58
Fig. 5-20 Misalignment of Pulleys58
Fig. 5-21 Adjusting Bolts at Input Shaft59
Fig. 5-22 Adjusting Anchor Bolts at Bearing Housing Assembly59
Blower Oil Changing and Breather Cleaning60
Fig. 5-23 Blower Schematics60
Fig. 5-24 Blower (Rear)60
Fig. 5-25 Blower (Front)60
Fig. 5-26 Blower Schematics61
Fig. 5-27 Breathers61
Airlock62
Fig. 5-28 Airlock62
Fig. 5-29 Checking Tip Clearance through the Access Door62
Shear Pin64
Fig. 5-31 Shear Pin64
Air System Relief Valves65
Fig. 5-33 Pressure Relief Valve65
Trouble Shooting66
Mobile Transfer Unit66
Pto Shaft68
Airlock69
Blower70
V-Belt Drive71
Mechanical Specifications72
Mechanical72
Bolt Torque73
Agri-Vac Parts List Addendum75
5614 Dlx, Hbr, Frl, Sch & DI Parts List76
Fig. 8-1 Exploded View 5614 DLX, HBR, FRL, SCH & DI77
6614 Dlx, Hbr , Frl, Sch & DI Parts List78
Fig. 8-2 Exploded View 6614 DLX, HBR, FRL, SCH & DI79
7614Hd Dlx, Hbr , Frl , Sch & DI Parts List80
Fig. 8-3 Exploded View 7614HD DLX, HBR, FRL, SCH & DI81
Fig. 8-4 Birds-Eye View 2016 Models83
5614 Dlx(2016) Hbr, Frl, Sch & DI Parts List84
Fig. 8-5 Exploded View 5614 DLX, (2016) HBR, FRL, SCH & DI85
6614 Dlx(2016) Hbr, Frl, Sch & DI Parts List86
Fig. 8-6 Exploded View 6614 DLX, (2016) HBR, FRL, SCH & DI87
7614 Dlx(2016) Hbr, Frl, Sch & DI Parts List88
Fig. 8-7 Exploded View 7614 HD DLX, (2016) HBR, FRL, SCH & DI89
7816 Dlx(2016) Hbr, Frl, Sch & DI Parts List90
Fig. 8-8 Exploded View 7816 DLX, (2016) HBR, FRL, SCH & DI91

Need help?

Do you have a question about the Walinga AGRI-VAC 5614 and is the answer not in the manual?

Walinga AGRI-VAC 5614 Specifications

General

Brand	Walinga
Model	AGRI-VAC 5614
Category	Farm Equipment
Language	English

Related product manuals

Walinga Ultra-Vac 6614D

58 pages

Walinga AGRI-VAC 5614 - User Manual

Table of Contents

Walinga AGRI-VAC 5614 Specifications

Related product manuals