ITEM PART DESCRIPTION NO.
NO. NO. REQ’D
ITEM PART DESCRIPTION NO.
NO. NO. REQ’D
4
Beginning S/N 149239
Use only genuine Walker
®
replacement parts.
BODY / CHASSIS ASSEMBLY
Seat Assembly
1 5103 Seat 1
2 2505 Leaf Spring 1
3 7223-4 Compression Spring 2
4 7845-1 Rubber Bumper (1.375 x .750) 2
5 5841-1 Retainer Washer 4
6 7434 Washer (3/8 x 1-1/4 x 1/4) 2
7 7440-5 Shock Mount (1-1/4 x 3/4) 2
Body Assembly
8 4105-5 Rear Body (Includes Item # 9) 1
9 4190-2 Insulation Foam Pad 1
10 5989-4 Dome Plug (3/8) 2
11 5989-3 Dome Plug (5/16) 2
12 4100-6 Front Body 1
13 4102-1 Body Guide / Upper 1
14 5845 Rubber Bumper (1.50 x 1.25) 2
15 5146 10mm Ball Stud 2
16 4145-2 Gas Spring Assembly 1
(Includes Item # 15)
17 5180 Edge Molding / Lever Opening 2
18 4504-3 Hinge (19") 1
19 5989-55 Dome Plug (1/2) 1
Chassis Assembly
20 4010-8 Precleaner / Battery Mount 1
21 4320-1 Gas Tank Mount 1
22 4215-10 Shock Mount / Body Lift Arm 1
23 4301-8 Chassis Frame 1
24 4102-2 Body Guide / Lower 1
25 7222 Extension Spring (1/4 x 3) 1
26 7854 Plastic Tip, Red 1
27 7383-1 Body Latch Hook 1
Spread Tail Wheel Assembly
28 4401-4 Washer (1-3/4 x 3/8 x 1/4 Thk) 1
29 4301-2 Fiberglide Thrust Washer 2
30 4301-3 Fiberglide Bearing 2
31 5830-3 Grease Fitting (45 Deg.) 1
32 4301-1 Tail Wheel Pivot 1
(Includes Items # 30, 31 & 33)
33 5830 Grease Fitting 4
34 8769-8 Dust Cap, Deck Caster 2
35 8769-6 Bearing Cone (1" ID) 4
36 8769-5 Bearing Cup (2 x 1-5/8) 4
37 8769-7 Seal 2
38 8765-11 Caster Wheel Fork 2
39 8767 Axle, Caster Wheel (5-1/8) 2
40 8768-2 Seal, Reverse Lip 4
41 8037 Bearing Cone (3/4 ID) 4
42 8768 Caster Wheel, Pneumatic (11 x 4.00-5) 2
8768-3 Tire, Pneumatic (11 x 4.00-5) *
8768-5 Caster Wheel (5 x 3) *
43 8766 Axle Nut (3/4-16) 2
Deck Support Arm & Hitch Assemblies
44 4301-10 Deck Arm Support Mount 1
45 6840-1 Support Arm Bushing (2-1/16) 2
46 4431-1 Deck Support Arm, LH (Includes Item # 33) 1
47 5775-2 Hitch Pin (#6) 2
48 4430-1 Deck Support Arm, RH (Includes Item # 33) 1
Tilt-Up Latch Assembly**
49 5847 Plastic Tip 1
50 5744-20 Spring Arm, Tilt-Up Latch 1
51 5744-10 Spring Pivot Bushing 1
52 5744-15 Compression Spring (3/8 x 5/8) 1
53 5744-13 Mount Angle, LH 1
54 5744-12 Hook, Tilt-Up Latch 1
55 5744-14 Mount Angle, RH 1
Fasteners
F002 10-24 Keps Nut 9
F004 1/4-20 Keps Nut 12
F005 1/4-20 ESNA Nut 1
F009 5/16-18 Whiz Locknut 17
F013 3/8-16 Whiz Locknut 2
F020 5/16-18 ESNA Nut 1
F025 10-24 x 3/8 PPHMS 7
F028 10-24 x 3/4 PPHMS 1
F029 1/4-20 x 1/2 Hex Bolt 4
F034 5/16-18 x 3/4 Hex Bolt 9
F038 3/8-16 x 1 Hex Bolt 1
F051 3/8 SAE Washer 1
F093 5/16-18 x 1 Hex Bolt 2
F116 1/4-20 x 1-1/4 Hex Bolt 1
F183 .312 x .700 x .074 Washer 2
F200 7/16-20 x 3 Grade 8 Bolt 2
F219 7/16-14 x 1-1/4 Hex Bolt 4
F227 3/8 x 1-1/4 x 1/8 Washer 2
F246 1/4-20 x 1/2 PTHMS 5
F256 7/16 SAE Washer 4
F257 3/8 x 1-11/16 Shoulder Bolt 2
F278 3/8 Split Lock Washer 1
F341 Coil Roll Pin (7/64 x 9/16) 1
F342 5/16 Conical Washer 2
F344 3/4-16 Slotted Hex Nut 2
F347 3/4 SAE Washer 2
F348 1/8 x 1-1/2 Cotter Pin 2
F381 1/4-20 Hex Nut 1
F388 3/8-16 x 2-1/2 Hex Bolt 2
F430 7/16-20 ESNA Nut 2
F475 1/4-20 x 1 PFH Screw 1
F477 1/4-20 x 5/8 Carriage Bolt 2
* Service Part Only
** Complete Tilt-Up Latch Assembly Kit available by ordering
kit # 5747.
To Next Page
Loading...
Need help?
General
