Wine Guardian SS025 - User Manual

To Next Page

Ducted Split

Wine Cellar Cooling Systems

Installation, Operation and Maintenance Guide

SS025, SS050, SS088, SS200

Manufactured by:

Syracuse, NY

Wine Guardian reserves the right, without notice, to make changes to this document at its sole discretion.

Please visit our web site for the most current version of the Wine Guardian manual and other literature.

Wine Guardian is a registered trademark (2,972,262) of Air Innovations, Inc.

Edition 10/2012

Main Page

Table of Contents2
Directory of Terms5
Illustrations6
Receiving, Inspecting and Unpacking the Wine Guardian Unit7
- Review the Packing Slip to Verify7
- Check the Fan Coil Unit for7
- Check the Condensing Unit for7
General Description8
- The Wine Guardian Ducted Split System Contains8
- Wine Guardian Fan Coil Unit9
- Electrical Controls9
- Condensing Unit9
- Accessories and Optional Equipment10
- Heating Coils10
- Duct Collars and Flexible Ducts10
- Extended Compressor Warranty10
- Low Ambient Option10
- Condensate Pump10
- Humidifier10
- Overview of the Wine Guardian Fan Coil11
- Ducted Split Systems Specifications Sheet13
- Wiring Diagram for 1/4-Ton and 1/2-Ton Units14
- Wiring Diagram for 1-Ton Unit15
- Wiring Diagram for 2-Ton Unit16
- 24-Volt Contactor Detail Sheet17
Safety18
- Safety Message Conventions18
- Danger18
- Warning18
- Caution18
- Lockout/Tagout Procedure19
- Safety Considerations19
- Safety Hazards19
- Electrical Hazards19
- Electrical Shock Hazards19
- Hot Parts Hazards19
- Moving Parts Hazards19
- Equipment Safety Interlocks20
- Main Power Switch20
Installation22
- Pre-Installation Test22
- To Test the Condensing Unit22
- Air Flow Diagram22
Planning the Installation24
- Addressing Items in the Planning Process24
- Performing a Pre-Installation Check24
Installing the Fan Coil Unit25
- Floor Mounting25
- Wall Mounting25
- Ceiling Mounting26
- Typical Mounting Arrangements26
- Handling and Installation26
- Floor Mount26
- Rod Mount27
- Shelf Mount27
- Optional Ductwork Connection on same Wall27
Installing the Ductwork and Grilles28
- Duct Collars28
- Location of Supply and Return Grilles28
- General Duct Recommendation29
- Reducing Noise from the Unit29
Installing the Condensate Drain Connection30
- Installing the Drain Line30
- Priming the Drain Trap30
Wiring the Fan Coil Unit for Power31
Installing the Condensing Unit32
- Installation of Interconnecting Refrigerant Lines (Suction and Liquid)32
- Split System Interconnecting Line Sizing Chart33
- Sample Piping Configurations34
- Leak Checking and Evacuation Process35
- Wiring35
- Refrigerant Charging36
- Determining the Amount of Charge36
- Procedures for Charging System with Head Pressure Control37
- Superheat38
- Sub-Cooling38
- Split System Operations Chart39
Installing the Remote Interface Controller and Communication Cable40
- Mounting the Remote Interface Controller40
Installing the Wine Guardian Remote Sensor42
- Mounting the Remote Sensor42
Joining the Communication Cable44
- Changing Jumper Positions44
Standard Controller Functions45
Inspection and Start up Checklists50
- Receiving and Inspecting50
- Handling and Installing50
- Starting-Up the Unit50
- Platform Mount50
Starting-Up and Operating the Wine Guardian Split System51
- Turn on the Unit51
- Testing the Fan51
- Running the Unit51
- Cycling the Unit52
- Setting the Remote Interface Controller52
- Regulating the Wine Cellar Temperature52
- Changing the Air Flow Direction52
Maintenance53
- General53
- Cleaning the Condensate Drain System54
- Cleaning the Humidifier54
- Heating Coil Option54
Maintenance Schedule55
- Monthly55
- Yearly55
Troubleshooting56
- Typical Start up Problems56
- Unit Does Not Start up56
- Power Switch Light Is on and the Remote Interface Controller Light Is off56
- Power Switch Light Is on and the Remote Interface Controller Light Is on56
- Unit Is Operating and Blows Evaporator Air57
- Cellar Temperature too Cold (below 51 Degrees) When Unit Is Running57
- Cellar Temperature too Cold (below 51 Degrees) When Unit Is Not Running57
- Humidity too Low or Supply Air Is too Cold, Without Optional Humidifier57
- Humidity too Low, Without Optional Humidifier58
- Humidity too Low, with Optional Humidifier58
- Humidity too High When Unit Is Running but Not Cooling58
- Humidity too High When Unit Is Not Running58
- Humidity too High When Unit Is Running and Cooling58
- Unit Operates but the Power Switch Light Is Not on59
- Unit Is Leaking Water59
- Unit Is Running Properly, but the Sound of the Unit Objectionable59
- High Pressure Switch Has Shut the Unit down60
- Instructions to Reset High Pressure Switch60
Advanced Troubleshooting61
- Evaporator Coil Is Freezing61
- High Pressure Switch Keeps Tripping61
- Unit Cycles on and off more than 8 Times/Hr61
- High Pitched or Loud Rubbing Noise, Clanking or Vibration61
- Replacing the Blowers61
Contact and Warranty Information62
- Contact Information62
- Warranty and Warranty Procedure62

Need help?

Do you have a question about the Wine Guardian SS025 and is the answer not in the manual?

Wine Guardian SS025 Specifications

General

Brand	Wine Guardian
Model	SS025
Category	Freezer
Language	English

Wine Guardian SS025 - User Manual

Table of Contents

Wine Guardian SS025 Specifications