Xtracycle 2016 EdgeRunner - Appendix; Fastener Torque Specifications

26
www.xtracycle.com
Derailleur/Shifting
RearDerailleurMountingBolt8-10Nm(70-86in-lb)
RearDerailleurCablePinchBolt4-5Nm(35-45in-lb)
RearDerailleurPulleyWheelBolt3-4Nm(27-36in-lb)
Brakes
DiscBrakeRotorToHub4-7Nm(36-60in-lb)
DiscBrakeCaliperMount6-9Nm(52-84in-lb)
BrakeLevers/Shifters6-8Nm(53-69in-lb)
Fenders
FenderBolts6-9Nm(53-78in-lb)
FenderBraceBolts2.5-4Nm(25-35in-lb)
Xtracycle Racklocks
5Nm(44in-lbs)
Xtracycle Tail Piece
5Nm(44in-lbs)(whileholdingnutsstationary)
Xtracycle KickBack
KickstandPlateBolt18-23Nm(160-200in-lbs)
ForwardAttachmentPointBolt5Nm(44in-lbs)
TelescopingLegBolts6Nm(53in-lb)
Xtracycle Flight Deck
DeckBolts2.5-4Nm(22-35in-lb)
Appendix
FastenerTorqueSpecications
Correct tightening torque of threaded fasteners is very important to your safety. Always tighten
fastenerstothecorrecttorque.Incaseofaconictbetweentheinstructionsinthismanualand
informationprovidedbyacomponentmanufacturer,consultwithyourdealerorthemanufacturer’s
customerservicerepresentativeforclarication.Boltsthataretootightcanstretchanddeform.
Bolts that are too loose can move and fatigue. Either mistake can lead to a sudden failure of the bolt.
Always use a correctly calibrated torque wrench to tighten critical fasteners on your bike. Carefully
followthetorquewrenchmanufacturer’sinstructionsonthecorrectwaytosetandusethetorque
wrench for accurate results.
FASTENER RECOMMENDED TORQUE
Headset/Handlebar
11i with threaded headset
ThreadedHeadsetLocknut16-24Nm
(142-212in-lb)
StemExpanderBolt(quilltype)17-22Nm
(150-195in-lb)
HandlebarBinderBolt(quilltype)17-22Nm
(150-195in-lb)
27D,30D,9E,10E,11iwiththreadlessheadset
StemBinderBolt(threadless)13.5-166Nm
(120-14453in-lb)
CompressionCap2-3Nm(20-26in-lb)
StemFaceplateBolts6Nm(53in-lb)13.5-19
Nm(120-168in-lb)
24D,8E
StemBinderBolt(threadless)5Nm(44in-lb)
CompressionCap2-3Nm(20-26in-lb)
StemFaceplateBolts5Nm(44in-lb)
Pedals
Pedals34.5-40Nm(307-354in-lb)
Wheels
AxleNut30-42Nm(260-372in-lb)
Seat
SeatPostBinder4-6.5Nm(36-60in-lb)
SeatRailBinder18-34Nm(160-300in-lb)