3-1
INSP
ADJ
E
MAINTENANCE INTERVAL CHART
MAINTENANCE INTERVAL CHART 3
Use the following chart as a guide to general maintenance intervals.
Dependant on operating conditions, adjust the maintenance intervals accordingly.
Item Remarks
Initial Every
Refer
to page
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
TOP COWLING
Top cowling fit Inspect 3-2
FUEL SYSTEM
Fuel line Inspect 3-2
Fuel filter Clean/inspect 3-3
Carburetor Clean 4-17
POWER UNIT
Water leakage Inspect —
Motor exterior Inspect —
Exhaust leakage Inspect —
Cooling water passage Clean/flush —
CONTROL SYSTEM
Carburetor synchroni-
zation
Inspect/adjust 3-6
Engine idling speed Inspect/adjust 3-7
Remote control shift
cable
Inspect/adjust 3-11
Remote control
throttle cable
Inspect/adjust 3-11
OIL INJECTION SYSTEM
Oil tank water drain Clean —
Oil pump lever Inspect/adjust 3-12
POWER TRIM AND TILT UNIT
Power trim and tilt fluid Inspect 3-16
LOWER UNIT
Gear oil Change 3-17
Lower unit leakage Inspect 3-19
Propeller Inspect 6-3, 6-27,
6-51
GENERAL
Anodes Inspect/replace 3-19
Battery Inspect/charge (every month) 3-20
Spark plugs Clean/adjust/replace 3-21
Wiring and connectors Adjust/reconnect —
Bolts and nuts Tighten —
Lubrication points Grease 3-23
To Next Page
Loading...
