Yamaha AR192 - Periodic Maintenance Chart

146 pages

Save Page as PDF

To Next Page

To Previous Page

Main Page

Table of Contents4
Identification Number Records7
Hull Identification Number (HIN)7
Primary Identification (PRI-ID) Number7
Engine Serial Number7
Emission Control Information8
Approval Label of Emission Control Certificate8
Manufactured Date Label9
Important Labels10
Warning Labels12
Limitations of Who May Operate the Boat16
Cruising Limitations17
Operational Requirements18
Required Equipment19
Additional Equipment Recommendations19
Hazard Information20
Boar Characteristics20
Night Operation21
Water-Skiing22
Rules of the Road23
Give-Way Vessel23
Crossing24
Meeting24
Overtaking24
Narrow Channels and Bends25
Fishing Vessel Right-Of-Way25
Sailing Vessel Right-Of-Way25
Reading Buoys and Other Markers25
Enjoy Your Boar Responsibly27
Boat Glossary28
Exterior Components29
Stern Components32
Helm Components33
Engine Components34
Boat Control Functions35
Engine Shut-Off Switch35
Battery Switch35
Main Switch36
Remote Control Lever36
Control Function Operation: Neutral37
Steering38
Reverse38
Tilt Lever39
Speedometer40
Multi-Function Tachometer40
Lcd41
Fuel Level, Fuel Used, Fuel Consumption Per Hour42
Water Depth, Water Temperature42
Fuel Consumption Per Gallon or Liter42
Battery Voltage, Boat Speed42
Engine Speed43
System Menu (LCD)43
Engine Hours, Trip Odometer43
Highest Speed43
Set Units44
Contrast44
Backlighting45
Read Param45
Calibrations45
Inst. Diag.46
Eng. Diag.47
Large Font47
Exit48
Warning Definition on LCD49
Engine Overheat Warning System49
Engine Oil Pressure Low Warning50
Check Engine Warning50
Low/High Battery Voltage Warning50
Left/Right Side Switches51
Courtesy Light Switch51
Bilge Pump Switch, Blower Switch51
Navigation and Anchor Lights Switch51
Horn Switch52
No-Wake Mode/Cruise Assist Switch52
Reverse RPM Control54
Switch Circuit Breakers55
Accessory Outlet55
Stereo System56
Seats57
Driver's Seat58
Passenger's Seat (SX192)59
Engine Hood60
Storage Compartments60
Anchor Storage Compartment60
Front Underseat Storage Compartments60
Ski Locker61
Rear Underseat Storage Compartment (Starboard)62
Rear Underseat Storage Compartment (Port)62
Glove Compartment63
Port Console Storage Compartment64
Wet Storage Compartment64
Front/Rear Walk-Through65
Windshield65
Stern Light66
Swim Platform and Ladder69
Wakeboard Tower (AR192)70
Bimini Top (AR192)72
Bimini Top (SX192)76
Fuel Requirement80
Engine Oil Requirement81
Checking the Engine Oil81
Draining the Bilge Water83
Pre-Operation Checklist87
Pre-Operation Check Points88
Steering System Checks88
Remote Control Lever Checks88
Fire Extinguisher Check89
Storing the Fire Extinguisher89
Operating the Fire Extinguisher90
Access Port Cap Check90
Jet Intake Check91
Engine Oil Level Check91
Battery Check92
Drain Plug Check92
Bilge Water Check92
Blower Switch Check93
Navigation and Anchor Lights Switch Check94
Horn Switch Check94
Engine Shutt-Off Cord (Lanyard) Check94
Cooling Water Pilot Outlet Check95
Post-Launch Checks95
Engine Shut-Off Switch Check95
Fuel Level Check96
Getting to Know Your Boat97
Learning to Operate Your Boat97
Starting the Engine97
Stopping the Engine99
Leaving a Dock100
Turning the Boat100
Boating with Passengers102
Stopping the Boat102
Boarding from the Water103
Boarding from a Dock or Landing Jetty103
Docking103
Beaching104
Anchoring105
Crossing Wakes and Swells105
Post-Operation Checks106
Trailering the Boat108
Hitch108
Trailering Checklist108
Backing Your Trailer109
Launching110
Loading110
Lifting111
Flushing the Cooling System112
Cleaning the Boat113
Basic Stain Guide115
Battery Care116
Long-Term Storage117
Fuel System117
Lubrication117
Grease Points117
Maintenance119
Owner's/Operator's Manual and Tool Kit119
Removing and Installing the Engine Cover119
Periodic Maintenance Chart121
Checking the Fuel System122
Checking the Air Filter123
Engine Oil and Oil Filter124
Checking the Steering Cable125
Checking the Remote Control Lever125
Checking the Shift Gate Mechanism125
Checking the Sacrificial Anode126
Replacing the Sacrificial Anode126
Maintaining the Battery127
Replenishing the Battery Fluid127
Recharging128
Specifications129
Troubleshooting Chart131
Jet Pump Clean-Out Procedure133
Jump-Starting134
Fuse Replacement135
Towing the Boat136
Warranty137
Sample Float Plan141
Index142

Related product manuals

Yamaha AR230 High output

114 pages

Yamaha AR192 - Periodic Maintenance Chart

Table of Contents

Related product manuals